Dometic CS-NC15 Používateľská príručka

ColdMachine 50, 54, 55, 84, 85, 86, 94, 95, 96, CS-NC15

Cooling unit

Installation and Operating Manual. . . . . . . 13

Kühlaggregat

Montage- und Bedienungsanleitung . . . . .38

Groupe frigorifique

Instructions de montage

et de service . . . . . . . . . . . . . . . . . . . . . . . . .63

Unidad frigorífica

Instrucciones de montaje y de uso . . . . . . .89

Unidade de refrigeração

Instruções de montagem e manual de

instruções . . . . . . . . . . . . . . . . . . . . . . . . . . 115

Gruppo refrigerante

Istruzioni di montaggio e d’uso . . . . . . . . 141

Koelaggregaat

Montagehandleiding en

gebruiksaanwijzing . . . . . . . . . . . . . . . . . . 167

Køleaggregat

Monterings- og betjeningsvejledning . . . 191

Kylaggregat

Monterings- och bruksanvisning . . . . . . . 213

Kjøleaggregat

Monterings- og bruksanvisning. . . . . . . . 235

Jäähdytysaggregaatti

Asennus- ja käyttöohje . . . . . . . . . . . . . . . 257

Холодильный агрегат

Инструкция по монтажу и эксплуатации 280

Agregat chłodzący

Instrukcja montażu i obsługi. . . . . . . . . . . 306

Chladiaci agregát

Návod na montáž a uvedenie

do prevádzky. . . . . . . . . . . . . . . . . . . . . . . 331

Chladicí agregát

Návod k montáži a obsluze . . . . . . . . . . . 355

Hűtőkészülék

Szerelési és használati útmutató . . . . . . . 379

EN

DE

FR

ES

PT

IT

NL

DA

SV

NO

FI

RU

PL

SK

CS

HU

REFRIGERATION

COOLING UNITS

Coldmachine-IO-16s.book Seite 1 Dienstag, 8. Mai 2018 2:06 14

https://manual-hub.com/

Coldmachine-IO-16s.book Seite 2 Dienstag, 8. Mai 2018 2:06 14

https://manual-hub.com/

Coldmachine

3

A

1

2

B

2

3

4

5

6

7

0

1

2

1

2

3

4

5

6

min max

Hauptschalter

Main Switch

Commutateur

principal

Kompressor ein

Compressor on

Compresseur en fonction

Fremdversorgung

External Voltage

Alimentation Extérieure

Speicherabruf

Discharge of Cold Accum.

Décharge de la Plaque

Temperature

Electronic

Control

2

Coldmachine-IO-16s.book Seite 3 Dienstag, 8. Mai 2018 2:06 14

https://manual-hub.com/

Coldmachine

4

VD-01, VD-04, VD-08

10 mm

3

VD-03

min. 30 mm

4

VD-02, VD-05, VD-18, VD-21

10 mm

5

Coldmachine-IO-16s.book Seite 4 Dienstag, 8. Mai 2018 2:06 14

https://manual-hub.com/

Coldmachine

5

VD-06

6

VD-07, VD-09

10 mm

1/3

2/3

7

VD-14N, VD-15

1/32/3

1234

5

8

Coldmachine-IO-16s.book Seite 5 Dienstag, 8. Mai 2018 2:06 14

https://manual-hub.com/

Coldmachine

6

VD-16

F

T

D

C

P

1

gn/ge

br

sw

gr

bl

9

VD-14N, VD-15

1

F

T

D

C

P

gn/ge

gr

bl

br

sw

0

b

a

Coldmachine-IO-16s.book Seite 6 Dienstag, 8. Mai 2018 2:06 14

https://manual-hub.com/

Coldmachine

7

2

1

3

c

AB

CD

d

Coldmachine-IO-16s.book Seite 7 Dienstag, 8. Mai 2018 2:06 14

https://manual-hub.com/

Coldmachine

8

1. 2.

e

g

SW21

SW19

SW16

f

2 – 3 mm

h

Coldmachine-IO-16s.book Seite 8 Dienstag, 8. Mai 2018 2:06 14

https://manual-hub.com/

Coldmachine

9

Ø

/mm²

l/m

12 V 24 V

0 2 4 6 8 10 12 14 16 18 20 22 24 26 28

0

2

6

10

14

i

VD-01, VD-02, VD-03, VD-04, VD-05,

VD-07, VD-08, VD-09, VD-18, VD-21

rt

swblgn/ge

sw/bl

2

3

4

5

6

7

0

1

br

12 3

4

j

Coldmachine-IO-16s.book Seite 9 Dienstag, 8. Mai 2018 2:06 14

https://manual-hub.com/

Coldmachine

10

bl br ge gn gr rt sw ws ∨

EN Blue Brown Yellow Green Grey Red Black White or

DE Blau Braun Gelb Grün Grau Rot Schwarz Weiss oder

FR Bleu Marron Jaune Vert Gris Rouge Noir Blanc ou

ES Azul Marrón Amarillo Verde Gris Rojo Negro Blanco o bien

PT Azul Castanho Amarelo Verde Cinzento Vermelho Preto Branco ou

IT Blu Marrone Giallo Verde Grigio Rosso Nero Bianco oppure

NL Blauw Bruin Geel Groen Grijs Rood Zwart Wit of

DA Blå Brun Gul Grøn Grå Rød Sort Hvid eller

SV Blå Brun Gul Grön Grå Röd Svart Vit eller

NO Blå Brun Gul Grønn Grå Rød Svart Hvit eller

FI Sininen Ruskea Keltainen Vihreä Harmaa Punainen Musta Valkoinen tai

RU Синий Коричневый Желтый Зеленый Серый Красный Черный Белый или

PL Niebieski Brązowy Żółty Zielony Szary Czerwony Czarny Biały lub

SK Modrá Hnedá Žltá Zelená Sivá Červená Čierna Biela alebo

CS Modrá Hněda Žlutá Zelená Šedá Červená Černá Bílá nebo

HU Kék Barna Sárga Zöld Szürke Piros Fekete Fehér vagy

12 3

4

br gn ws

rt

T

P

C

sw/bl

VD-06

k

Coldmachine-IO-16s.book Seite 10 Dienstag, 8. Mai 2018 2:06 14

https://manual-hub.com/

Coldmachine

11

257 mm

81 mm

9,50 mm

128,50 mm

360 mm

281 mm

l

Coldmachine-IO-16s.book Seite 11 Dienstag, 8. Mai 2018 2:06 14

https://manual-hub.com/

Coldmachine

12

~ 215 mm

~ 310 mm

m

Coldmachine-IO-16s.book Seite 12 Dienstag, 8. Mai 2018 2:06 14

https://manual-hub.com/

EN

Coldmachine

13

Please read this instruction manual carefully before installation and first

use, and store it in a safe place. If you pass on the product to another

person, hand over this instruction manual along with it.

Contents

1 Explanation of symbols . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14

2 Safety instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14

3 Scope of delivery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16

4 Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17

5 Intended use . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17

6 Technical description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17

7 Installing the cooling unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19

8 Using the cooling unit. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25

9 Use coolant accumulator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27

10 Guarantee . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28

11 Disposal. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29

12 Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29

13 Technical data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32

Coldmachine-IO-16s.book Seite 13 Dienstag, 8. Mai 2018 2:06 14

https://manual-hub.com/

EN

Explanation of symbols Coldmachine

14

1 Explanation of symbols

D

!

A

I

2 Safety instructions

The manufacturer accepts no liability for damage in the following cases:

• Faulty assembly or connection

• Damage to the product resulting from mechanical influences and incorrect

connection voltage

• Alterations to the product without express permission from the manufacturer

• Use for purposes other than those described in the operating manual

2.1 General safety

DDANGER!

•Danger of fatalinjuries!

When using the device on boats: if the device is powered by the

mains, ensure that the power supply has a residual current circuit

breaker!

DANGER!

Safety instruction: Failure to observe this instruction will cause fatal or

serious injury.

WARNING!

Safety instruction: Failure to observe this instruction can cause fatal or

serious injury.

CAUTION!

Safety instruction: Failure to observe this instruction can lead to injury.

NOTICE!

Failure to observe this instruction can cause material damage and impair

the function of the product.

NOTE

Supplementary information for operating the product.

Coldmachine-IO-16s.book Seite 14 Dienstag, 8. Mai 2018 2:06 14

https://manual-hub.com/

EN

Coldmachine Safety instructions

15

!WARNING!

• This device may only be installed and repaired by a qualified

technician. Inadequate repairs can lead to considerable hazards.

Should your device need to be repaired, please contact customer

services.

• Do not operate the device if it is visibly damaged.

• Do not open the refrigerant circuit under any circumstances. An

exception to this is when the device has to be disconnected for return

shipping (chapter “Installing the external temperature regulator” on

page 22).

• Set up the device in a dry location where it is protected against splash-

ing water.

• Do not place the device near naked flames or other heat sources

(heaters, direct sunlight, gas ovens etc.).

• Make sure that the compressor is sufficiently ventilated.

•Electronic devices are not toys!

Always keep and use the device out of the reach of children.

• People (including children) whose physical, sensory or mental

capacities or whose lack of experience or knowledge prevent them

from using this product safely should not use it without the supervision

or instruction of a responsible person.

• Before you start up the device for the first time, check that the

operatingvoltage matches the battery voltage (see type plate).

• If the connection cable is damaged, it must be replaced to prevent

possible electrical hazards. Only replace a damaged connection

cable with a connection cable of the same type and specifications.

• Do not store any explosive substances, such as spray cans with

propellants in the device.

Coldmachine-IO-16s.book Seite 15 Dienstag, 8. Mai 2018 2:06 14

https://manual-hub.com/

EN

Scope of delivery Coldmachine

16

2.2 Operating the device safely

DDANGER! Danger of fatal injuries!

• Do not touch exposed cables with your bare hands. This especially

applies when operating the device from the AC mains.

ANOTICE!

• Never use cleaners that contain sand, acids or solvents to clean the

vaporiser.

• Protect the device against rain and moisture.

• Disconnect the cooling device and other consumer units from the

battery before you connect the quick charging device.

INOTE

• Disconnect the device if you are not going to use it for a prolonged

period.

2.3 Safety precautions when handling batteries

!CAUTION! Danger of injury!

• Batteries contain aggressive and caustic acids. Avoid battery fluid

coming into contact with your body. If your skin does come into

contact with battery fluid, wash the part of your body in question

thoroughly with water.

• If you connect the device to a battery, make sure that no food comes

into contact with the battery acid.

3Scope of delivery

Quantity Description

1 Cooling unit or vaporiser

1 Operating manual

Coldmachine-IO-16s.book Seite 16 Dienstag, 8. Mai 2018 2:06 14

https://manual-hub.com/

EN

Coldmachine Accessories

17

4Accessories

If you wish to operate the cooling unit from the 230 V AC mains, please use one of

the following rectifiers.

Available as accessory (not included in scope of delivery):

5 Intended use

The cooling unit is suited for building your own refrigerator or cooler.

The cooler unit is suitable for cooling and freezing food. The device is also suitable

for use on boats.

!

6 Technical description

The cooling units are suitable for use with 12 V or 24 V DC voltage and can therefore

be used for camping or on boats. Furthermore, you can connect them to a 230 V

mains supply via the rectifiers (see chapter “Accessories” on page 17).

When used on boats, the cooling unit can withstand a constant heeling of 30°.

The cooling unit must be used together with a vaporiser. In addition, you can use an

accumulator with or without TEC control. The CS-NC15 comprises a cooling unit

and a vaporiser.

Use the continuously variable thermostat on the vaporiser to set the desired

temperature.

Description Item number

CoolPower EPS100 rectifier

For devices with BD35F compressor (50/80/CS/CS series)

9600000440

CoolPower MPS35 rectifier

For devices with BD35F compressor (50/80/CS/CS series)

9600000445

CoolPower MPS50 rectifier

For devices with BD50F compressor (90 series)

9600000441

CAUTION! Health hazard!

Please check if the cooling capacity of the device is suitable for storing

the food or medicine you wish to cool.

Coldmachine-IO-16s.book Seite 17 Dienstag, 8. Mai 2018 2:06 14

https://manual-hub.com/

EN

Technical description Coldmachine

18

The accumulator and TEC program control ensure a high cooling capacity

and improve the unit’s efficiency. The accumulator is charged when there is

a sufficient supply of power (for example when powered by a mains adapter). In the

event of accumulator usage or under-voltage, the coolant is drawn from the

accumulator until it is empty. Thus, no power is taken from the battery during this

time.

The TEC program control always ensures that

• Cold energy is stored if there is excess electrical energy (external supply of power

by a generator).

• The coolant accumulator can be used at any time to ensure that the complete

battery power is used for other consumers.

• Stored cold energy is automatically retrieved to preserve the interior cooling

temperature of the cooling area, once the battery capacity is exhausted.

I

6.1 Battery monitor

The cooling device is equipped with an electronic device to protect against revers-

ing the polarity when connecting to a battery. To protect the battery, the cooling

device switches off automatically if the voltage is insufficient (see following table).

Devices without TEC control

Devices with TEC control

NOTE

Further information on the coolant accumulator can be found in chapter

“Use coolant accumulator” on page 27.

Connection voltage Switch-off voltage Restart voltage

12 V 10.4 V 11.7 V

24 V 22.8 V 24.2 V

Connection voltage Switch-off voltage Restart voltage

12 V 10.7 V 13.0 V

24 V 22.0 V 26.0 V

Coldmachine-IO-16s.book Seite 18 Dienstag, 8. Mai 2018 2:06 14

https://manual-hub.com/

EN

Coldmachine Installing the cooling unit

19

7 Installing the cooling unit

!

7.1 Tools required

For installation and assembly, you will need the following tools:

•Drill

• Screwdriver

• Open-ended spanner: 16 mm, 19 mm and 21 mm

• Sealant and PUR foam

• Cable, cable lugs and cable clips

•Ester oil

7.2 Notes on the cooling container

Permitted cooling area contents

Make sure that maximum cooling area contents specified are not exceeded for the

respective vaporiser type (see chapter “Technical data” on page 32).

Minimum insulation

The maximum cooling area contents are based on a minimum insulation thickness of

35 mm of foam polyurethane with a density of 40 kg/m³. If other insulating materials

are used such as styrofoam, double the wall thickness to attain the same level of heat

insulation.

Installing the vaporiser

The vaporiser must be installed in the cooling container (except CS-NC15, the

vaporiser is premounted).

Observe the following in the process:

• Correct installation position (fig. 3, page 4 up to fig. 9, page 6)

• Arrangement in the cooling container as far to the top as possible

• Install a least 10 mm from the wall (not VD-14N and VD-15).

WARNING!

The installation may only be performed by a qualified technician.

Coldmachine-IO-16s.book Seite 19 Dienstag, 8. Mai 2018 2:06 14

https://manual-hub.com/

EN

Installing the cooling unit Coldmachine

20

A

Connecting the vaporiser

➤Connect the vaporisers VD-14N and VD-15 in accordance with fig. 0, page 6.

➤Connect vaporiser VD-16 according to fig. 9, page 6.

➤Connect other vaporisers according to fig. j, page 9.

Keys for the illustrations

NOTICE!

For cooling units without valve couplings (ready-to install units): Do not

open the refrigerant circuit during installation. You may have to make the

wall openings larger to be able to slide the vaporiser through them

(fig. a, page 6). Or alternatively, you create an opening that allows you

to install the cooling lines at the top (fig. b, page 6).

No. in fig. 8,

page 5 Explanation

1 DC fan

2 Thermostat button

3Connection plug for DC fan

4Thermostat

5 Connection cable

No. in fig. 9,

page 6 Explanation

1 Connection cable

No. in fig. 0,

page 6 Explanation

1 Connection cable

Coldmachine-IO-16s.book Seite 20 Dienstag, 8. Mai 2018 2:06 14

https://manual-hub.com/

Stránka sa načítava ...

Dometic CS-NC15 Používateľská príručka

Dometic CS-NC15 Používateľská príručka

V iných jazykoch

Súvisiace články