Simplicity 095402-0114-B1 Používateľská príručka

English

bg cs hr slet hu

Èeština

lt lv pl ro ru

eesti keel Hrvatski Latviešu Polski Ðóññêèé

Românã

Áúëãàðñêè LietuviųMagyar Slovenšèina

Operator’s Manual

Èíñòðóêöèè çà åêñïëîàòàöèÿ

Návod k obsluze

Kasutusjuhend

Priruènik za operatora

Kezelési útmutató

Naudojimo instrukcija

Operatora rokasgrāmata

Instrukcja obs³ugi

Manual de utilizare

Ðóêîâîäñòâî ïî ýêñïëóàòàöèè

Priroènik za uporabo

Form No. 277098EST A

E 2008 Briggs & Stratton Corporation,

Briggs & Stratton is a registered trademark

of Briggs & Stratton Corporation

Model 90000

I/C

475/525 Seriest

Power Builtt 475/525 Seriest

BRIGGSandSTRATTON.COM

7 8

4 BRIGGSandSTRATTON.COM

General Information

For replacement parts or technical assistance, record below the engine model, type, and

code numbers along with the date of purchase. These numbers are located on your

engine (see the Features and Controls page).

Date of purchase:

Engine model:

MM/DD/YYYY

Model: Code:Type:

Engine Power Rating Information

The gross power rating for individual gas engine models is labeled in accordance with

SAE (Society of Automotive Engineers) code J1940 (Small Engine Power & Torque

Rating Procedure), and rating performance has been obtained and corrected in

accordance with SAE J1995 (Revision 2002-05). Torque values are derived at 3060

RPM; horsepower values are derived at 3600 RPM. Actual gross engine power will be

lower and is affected by, among other things, ambient operating conditions and

engine-to-engine variability. Given both the wide array of products on which engines are

placed and the variety of environmental issues applicable to operating the equipment,

the gas engine will not develop the rated gross power when used in a given piece of

power equipment (actual “on-site” or net power). This difference is due to a variety of

factors including, but not limited to, accessories (air cleaner, exhaust, charging, cooling,

carburetor, fuel pump, etc.), application limitations, ambient operating conditions

(temperature, humidity, altitude), and engine-to-engine variability. Due to manufacturing

and capacity limitations, Briggs & Stratton may substitute an engine of higher rated

power for this Series engine.

Operator Safety

Explosion

Toxic Fumes

Moving Parts

Shock

Hot Surface

Kickback

Fire

Fuel Shutoff

Read Manual

Choke

Oil

Fuel

On Off

Stop

Wear Eye

Protection

Slow

Fast

SAFETY AND CONTROL SYMBOLS

Hazardous

Chemical

Frostbite

The safety alert symbol

is used to identify safety information about hazards that can

result in personal injury . A signal word (DANGER, WARNING, or CAUTION) is used with the

alert symbol to indicate the likelihood and the potential severity of injury. In addition, a hazard

symbol may be used to represent the type of hazard.

DANGER indicates a hazard which, if not avoided, will result in death or

serious injury.

WARNING indicates a hazard which, if not avoided, could result in death or

serious injury.

CAUTION indicates a hazard which, if not avoided, might result in minor or

moderate injury.

CAUTION, when used without the alert symbol, indicates a situation that

could result in damage to the product.

The engine exhaust from this product contains chemicals known to

the State of California t o c ause cancer, birth defects, or other

reproductive harm.

WARNING

Briggs & Stratton does not approve or authorize the use of these

engines on 3-wheel All Terrain Vehicles (ATVs), motor bikes,

fun/ recreational go-karts, aircraft products, or vehicles intended for

use in competitive events. Use of these engines in such applications

could result in property damage, serious injury (including paralysis),

or even death.

WARNING

CAUTION: This engine was shipped from Briggs & Stratton without oil. Before you start

the engine, make sure you add oil according to the instructions in this manual. If you

start the engine without oil, it will be damaged beyond repair and will not be covered

under warranty.

WARNING

Gasoline and its vapors are extremely flammable and explosive.

Fire or explosion can cause severe burns or death.

When Adding Fuel

• Turn engine off and let engine cool at least 2 minutes before removing the fuel cap.

• Fill fuel tank outdoors or in well-ventilated area.

• Do not overfill fuel tank. Fill tank to approximately 1.5 inches (38 mm) below top of

neck to allow for fuel expansion.

• Keep gasoline away from sparks, open flames, pilot lights, heat, and other ignition

sources.

• Check fuel lines, tank, cap, and fittings frequently for cracks or leaks. Replace if

necessary

• If fuel spills, wait until it evaporates before starting engine.

When Starting Engine

• Ensure that spark plug, muffler, fuel cap and air cleaner (if equipped) are in place

and secured.

• Do not crank engine with spark plug removed.

• If engine floods, set choke (if equipped) to OPEN/RUN position, move throttle (if

equipped) to FAST position and crank until engine starts.

When Operating Equipment

• Do not tip engine or equipment at angle which causes gasoline to spill.

• Do not choke the carburetor to stop engine.

• Never start or run the engine with the air cleaner assembly (if equipped) or the air

filter (if equipped) removed.

When Changing Oil

• If you drain the oil from the t op oil fill tube, the fuel tank must be empty or fuel can

leak out and result in a fire or explosion.

When Transporting Equipment

• Transport with fuel tank EMPTY or with fuel shut-off valve OFF.

When Storing Gasoline Or Equipment With Fuel In Tank

• Store away from f urnaces, stoves, water heaters or other appliances that have pilot

light or other ignition source because they can ignite gasoline vapors.

Starting engine creates sparking.

Sparking can ignite nearby flammable gases.

Explosion and fire could result.

WARNING

• If there is natural or LP gas leakage in area, do not start engine.

• Do not use pressurized starting fluids because vapors are flammable.

Engines give off carbon monoxide, an odorless, colorless, poison gas.

Breathing carbon monoxide can cause nausea, fainting or death.

WARNING

• Start and run engine outdoors.

• Do not start or run engine in enclosed area, even if doors or windows are open.

Rapid r etraction of starter cord (kickback) will pull hand and arm toward

engine faster than you can let go.

Broken bones, fractures, bruises or sprains could result.

WARNING

• When starting engine, pull the starter cord slowly until resistance is felt and then pull

rapidly to avoid kickback.

• Remove all external equipment/engine loads before starting engine.

• Direct-coupled equipment components such as, but not limited to, blades, impellers,

pulleys, sprockets, etc., must be securely attached.

Rotating parts can contact or entangle hands, feet, hair, clothing, or

accessories.

Traumatic amputation or severe laceration can result.

WARNING

• Operate equipment with guards in place.

• Keep hands and feet away from rotating parts.

• Tie up long hair and remove jewelry.

• Do not wear loose-fitting clothing, dangling drawstrings or items that could become

caught.

Running engines produce heat. Engine parts, especially muffler , become

extremely hot.

Severe thermal burns can occur on contact.

Combustible debris, such as leaves, grass, brush, etc. can catch fire.

WARNING

• Allow muffler, engine cylinder and fins to cool before touching.

• Remove accumulated debris from muffler area and cylinder area.

• Install and maintain in working order a spark arrester before using equipment on

forest-covered, grass-covered, brush-covered unimproved land. The state of

California requires this (Section 4442 of the California Public Resources Code).

Other states may have similar laws. Federal laws apply on federal land.

Unintentional sparking can result in fire or electric shock.

Unintentional start-up can result in entanglement, traumatic amputation,

or laceration.

Fire hazard

WARNING

Before performing adjustments or repairs:

• Disconnect the spark plug wire and keep it away from the spark plug.

• Disconnect battery at negative terminal (only engines with electric start.)

• Use only correct tools.

• Do not tamper with governor spring, links or other parts to increase engine speed.

• Replacement parts must be the same and installed in the same position as the

original parts.

• Do not strike the flywheel with a hammer or hard object because the flywheel may

later shatter during operation.

When testing for spark:

• Use approved spark plug t ester.

• Do not check for spark with spark plug removed.

6 BRIGGSandSTRATTON.COM

Features and Controls

Compare the illustration

with your engine to familiarize yourself with the location of

various features and controls.

A. Engine Identification

Model Type Code

B. Spark Plug

C. Air Cleaner

D. Choke

E. Starter Cord Handle

F. Finger Guard

G. Throttle Control (optional)

H. Stop Switch (optional)

I. Fuel Tank and Cap

J. Oil Drain Plug

K. Oil Fill

L. Muffler

Muffler Guard (optional)

Spark Arrester (optional)

M. Gear Reduction Unit (optional)

Operation

Oil capacity (see the Specifications section)

Oil Recommendations

We recommend the use of Briggs & Stratton Warranty Certified oils for best

performance. Other high-quality detergent oils are acceptable if classified for service SF,

SG, SH, SJ or higher. Do not use special additives.

Outdoor temperatures determine the proper oil viscosity for the engine. Use the chart to

select the best viscosity for the outdoor temperature range expected.

SAE 30

10W-30

Synthetic 5W-30

5W-30

°F °C

* Below 40°F(4°C) the use of SAE 30 will result in hard starting.

** Above 80°F(27°C) the use of 10W-30 may cause increased oil consumption. Check

oil level more frequently.

How To Check/Add Oil - Figure

Before adding or checking the oil

• Place engine level.

• Clean the oil fill area of any debris.

1. Remove the oil fill cap (A, Figure 2).

2. To add oil, pour the oil slowly into the engine oil fill (B). Fill to point of overflowing.

3. Replace and tighten the oil fill cap.

Fuel Recommendations

Fuel must meet these requirements:

• Clean, fresh, unleaded gasoline.

• A minimum of 87 octane/87 AKI (91 RON). High altitude use, see below.

• Gasoline with up to 10% ethanol (gasohol) or up to 15% MTBE (methyl tertiary

butyl ether) is acceptable.

CAUTION: Do not use unapproved gasolines, such as E85. Do not mix oil in gasoline or

modify the engine to run on alternate fuels. This will damage the engine components and

void the engine warranty.

To protect the fuel system from gum formation, mix a fuel stabilizer into the fuel. See

Storage. All fuel is not the same. If starting or performance problems occur, change fuel

providers or change brands. This engine is certified to operate on gasoline. The

emissions control system for t his engine is EM (Engine Modifications).

High Altitude

At altitudes over 5,000 feet (1524 meters), a minimum 85 octane/85 AKI (89 RON)

gasoline is acceptable. To remain emissions compliant, high altitude adjustment is

required. Operation without this adjustment will cause decreased performance,

increased fuel consumption, and increased emissions. See a Briggs & Stratton

Authorized Dealer for high altitude adjustment information.

Operation of the engine at altitudes below 2,500 feet (762 meters) with the high altitude

kit is not recommended.

How To Add Fuel - Figure

WARNING

Gasoline and its vapors are extremely flammable and explosive.

Fire or explosion can cause severe burns or death.

When Adding Fuel

• Turn engine off and let engine cool at least 2 minutes before removing the fuel cap.

• Fill fuel tank outdoors or in well-ventilated area.

• Do not overfill fuel tank. Fill tank to approximately 1.5 inches (38 mm) below top of

neck to allow for fuel expansion.

• Keep gasoline away from sparks, open flames, pilot lights, heat, and other ignition

sources.

• Check fuel lines, tank, cap, and fittings frequently for cracks or leaks. Replace if

necessary.

• If fuel spills, wait until it evaporates before starting engine.

1. Clean the fuel cap area of dirt and debris. Remove the fuel cap (A) (Figure 3).

2. Fill the fuel tank (B) with gasoline. To allow for expansion of the gasoline, do not fill

above the bottom of the fuel tank neck (C).

3. Reinstall the fuel cap.

How To Start The Engine - Figure

Rapid r etraction of starter cord (kickback) will pull hand and arm toward

engine faster than you can let go.

Broken bones, fractures, bruises or sprains could result.

WARNING

• When starting engine, pull the starter cord slowly until resistance is felt and then pull

rapidly to avoid kickback.

WARNING

Gasoline and its vapors are extremely flammable and explosive.

Fire or explosion can cause severe burns or death.

When Starting Engine

• Ensure that spark plug, muffler, fuel cap and air cleaner are in place and secured.

• Do not crank engine with spark plug removed.

• If engine floods, set choke (if equipped) to open /run position, move throttle (if

equipped) to fast position and crank until engine starts.

Engines give off carbon monoxide, an odorless, colorless, poison gas.

Breathing carbon monoxide can cause nausea, fainting or death.

WARNING

• Start and run engine outdoors.

• Do not start or run engine in enclosed area, even if doors or windows are open.

CAUTION: This engine was shipped from Briggs & Stratton without oil. Before you start

the engine, make sure you add oil according to the instructions in this manual. If you

start the engine without oil, it will be damaged beyond repair and will not be covered

under warranty.

1. Check the oil level. See the How To Check/Add Oil section.

2. Make sure equipment drive controls, if equipped, are disengaged. See the equipment

manual for location and operation of these controls.

3. Move the choke control lever (A) to the choke

position (Figure 4).

Note: Choke is usually unnecessary when restarting a warm engine.

4. Move the throttle control lever (B), if equipped, to the fast

position. Operate

the engine with the t hrottle control lever in the fast position.

5. On engines equipped with a stop switch (C), move the s witch to the on position.

6. Firmly hold the starter cord handle (D). Pull the starter cord handle slowly until

resistance is felt, then pull rapidly.

Note: If the engine does not start after three attempts, go to

BRIGGSandSTRATTON.COM or call 1-800-233-3723 (in USA).

WARNING: Rapid retraction of the starter cord (kickback) will pull your

hand and arm toward the engine faster than you can let go. Broken bones,

fractures, bruises or sprains could result. When starting engine, pull the starter cord

slowly until resistance is felt and then pull rapidly to avoid kickback.

7. As the engine warms up, move the choke control (A)totherun

position.

How To Stop The Engine - Figure

WARNING

Gasoline and its vapors are extremely flammable and explosive.

Fire or explosion can cause severe burns or death.

• Do not choke the carburetor to stop engine.

On models equipped with a throttle control lever (B), move the throttle control lever to

slow

and then to the stop position (see Figure 4).

Move the stop switch (C) to the stop position.

Maintenance

Use only original equipment replacement parts. Other parts may not perform as

well, may damage the unit, and may result in injury. In addition, use of other parts

may void your warranty.

We recommend that you see any Briggs & Stratton Authorized Dealer for all

maintenance and service of the engine and engine parts.

CAUTION: All the components used to build this engine must remain in place for proper

operation.

Emissions Control

Maintenance, replacement, or repair of the emissions control devices and systems

may be performed by any non-road engine repair establishment or individual.

However, to obtain “no charge” emissions control service, the work must be performed

by a factory authorized dealer. See the Emissions Warranty.

Unintentional sparking can result in fire or electric shock.

Unintentional start-up can result in entanglement, traumatic amputation,

or laceration.

Fire hazard

WARNING

Before performing adjustments or repairs:

• Disconnect the spark plug wire and keep it away from the spark plug.

• Use only correct tools.

• Do not tamper with governor spring, links or other parts to increase engine speed.

• Replacement parts must be the same and installed in the same position as the

original parts.

• Do not strike the flywheel with a hammer or hard object because the flywheel may

later shatter during operation.

When testing for spark:

• Use approved spark plug t ester.

• Do not check for spark with spark plug removed.

Maintenance Chart

First 5 Hours

• Change oil

Every8HoursorDaily

• Check engine oil level

• Clean area around muffler and controls

• Clean finger guard

Every 25 Hours or Annually

• Clean air filter *

• Clean pre-cleaner *

Every 50 Hours or Annually

• Change engine oil

• Check muffler and spark arrester

Every 100 Hours

• Change gear reduction oil (if equipped)

Annually

• Replace air filter

• Replace pre-cleaner

• Replace spark plug

• Clean air cooling system *

* In dusty conditions or when airborne debris is present, clean more often.

Carburetor Adjustment

Never make adjustments to the carburetor. The carburetor was set at the factory to

operate efficiently under most conditions. However, if adjustments are required, see any

Briggs & Stratton Authorized Dealer for service.

CAUTION: The manufacturer of the equipment on which t his engine is installed specifies

the top speed at which the engine will be operated. Do not exceed this speed.

How To Replace The Spark Plug - Figure

Check the gap (A, Figure 5) with a wire gauge (B). If necessary, reset the gap. Install

and tighten the spark plug to the recommended torque. For gap setting or torque, see the

Specifications section.

Note: In some areas, local law requires using a resistor spark plug to suppress ignition

signals. If this engine was originally equipped with a resistor spark plug, use the same

type for replacement.

Inspect Muffler And Spark Arrester - Figure

Running engines produce heat. Engine parts, especially muffler , become

extremely hot.

Severe thermal burns can occur on contact.

Combustible debris, such as leaves, grass, brush, etc. can catch fire.

WARNING

• Allow muffler, engine cylinder and fins to cool before touching.

• Remove accumulated debris from muffler area and cylinder area.

• Install and maintain in working order a spark arrester before using equipment on

forest-covered, grass-covered, brush-covered unimproved land. The state of

California requires this (Section 4442 of the California Public Resources Code).

Other states may have similar laws. Federal laws apply on federal land.

Inspect the muffler ( A, Figure 6) for cracks, corrosion, or other damage. Remove the

spark arrester (B), if equipped, and inspect for damage or carbon blockage. If

replacement parts are required, make sure to use only original equipment replacement

parts.

WARNING: Replacement parts must be the same and installed in the same

position as the original parts or fire could result.

BRIGGSandSTRATTON.COM

How To Change The Oil - Figure

7 8

CAUTION: Used oil is a hazardous waste product and must be disposed of properly. Do

not discard with household waste. Check with y our local authorities, service center, or

dealer for safe disposal/ recycling f acilities.

Remove Oil

1. With engine off but still warm, disconnect the spark plug wire (A) and keep it away

from the spark plug (Figure 7).

2. Remove the oil drain plug (B, Figure 8). Drain the oil into an approved receptacle.

Note: Any of the oil drain plugs (C) shown may be installed in the engine.

3. After the oil has drained, install and tighten the oil drain plug.

Add oil

• Place engine level.

• Clean the oil fill area of any debris.

• See the Specifications section for oil capacity.

1. Remove the oil fill cap (D, Figure 8).

2. Pour the oil slowly into the engine oil fill (E). Fill to point of overflowing.

3. Replace and tighten the oil fill cap.

How To Service The Air Filter - Figure

9 10

WARNING

Gasoline and its vapors are extremely flammable and explosive.

Fire or explosion can cause severe burns or death.

• Never start or run the engine with the air cleaner assembly or the air filter removed.

CAUTION: Do not use pressurized air or solvents to clean the filter. Pressurized air can

damage the filter and solvents will dissolve the filter.

The air cleaner system uses a pleated filter with an optional pre-cleaner. The pre-cleaner

can be washed and reused.

1. Push in the locking tabs (A) and pull off the cover (B).SeeFigure9.

2. Remove the filter (D). See Figure 10.

3. To loosen debris, gently tap the filter on a hard surface. If the filter is excessively

dirty, replace with a new filter.

4. Push the end of the filter into the base as shown. Make sure filter fits securely in the

base.

5. Install the cover. Make sure both locking tabs are secure.

How To Change The Gear Reduction Oil - Figure

If your engine is equipped with a gear reduction unit, service as follows.

1. Remove the oil fill plug (B) and the oil level plug (C).

2. Remove the oil drain plug (A, Figure 11) and drain the oil into an appropriate

receptacle.

3. Install and tighten the oil drain plug.

4. To refill, slowly pour gear lube into the oil fill hole (see Specifications section).

Continue to pour until the oil runs out of the oil level hole.

5. Install and tighten the oil level plug.

6. Install and tighten the oil fill plug.

Important: The oil fill plug has a vent hole (D) and must be installed on the top of t he

gear case cover as shown.

How To Clean The Air Cooling System - Figure

Running engines produce heat. Engine parts, especially muffler , become

extremely hot.

Severe thermal burns can occur on contact.

Combustible debris, such as leaves, grass, brush, etc. can catch fire.

WARNING

• Allow muffler, engine cylinder and fins to cool before touching.

• Remove accumulated debris from muffler area and cylinder area.

CAUTION: Do not use water to clean the engine. Water could contaminate the fuel

system. Use a brush or dry cloth to clean the engine.

This is an air cooled engine. Dirt or debris can restrict air flow and cause the engine to

overheat, resulting in poor performance and reduced engine life.

Use a brush or dry cloth to remove debris from the finger guard (A) (Figure 12). Keep

linkage, springs and controls (B) clean. Keep the area around and behind the muffler (C)

free of any combustible debris.

Storage

WARNING

Gasoline and its vapors are extremely flammable and explosive.

Fire or explosion can cause severe burns or death.

When Storing Gasoline Or Equipment With Fuel In Tank

• Store away from f urnaces, stoves, water heaters or other appliances that have pilot

lights or other ignition sources because they can ignite gasoline vapors.

Fuel System

Fuel can become stale when stored over 30 days. Stale fuel causes acid and gum

deposits to form in the fuel system or on essential carburetor parts. To keep fuel fresh,

use Briggs & Stratton FRESH START

fuel stabilizer, available as a liquid additive or a

drip concentrate cartridge.

There is no need to drain gasoline from the engine if a fuel stabilizer is added according

to instructions. Run the engine for 2 minutes to circulate the stabilizer throughout the fuel

system. The engine and fuel can then be stored up to 24 months.

If gasoline in the engine has not been treated with a fuel stabilizer, it must be drained into

an approved container. Run the engine until it stops from lack of fuel. The use of a fuel

stabilizer in the storage container is recommended to maintain freshness.

Engine Oil

While the engine is still warm, change the engine oil.

Troubleshooting

Need Assistance? Go to BRIGGSandSTRATTON.COM or call 1-800-233-3723.

Specifications

Engine Specifications

Model 90000

Displacement 9.02 ci (148 cc)

Bore 2.562 in (65.08 mm)

Stroke 1.750 in (44.45 mm)

Oil Capacity 18 -- 20 oz (0.54 -- 0.59 L)

Gear Reduction Oil 80W-90

Tune-up Specifications *

Model 90000

Spark Plug Gap 0.030 in (0.76 mm)

Spark Plug Torque 180 lb-in (20 Nm)

Armature Air Gap 0.006 - 0.010 in (0.15 - 0.25 mm)

Intake Valve Clearance 0.005 - 0.007 in (0.13 - 0.18 mm)

Exhaust Valve Clearance 0.007 - 0.009 in (0.18 - 0.23 mm)

* Engine power will decrease 3.5% for each 1,000 feet (300 meters) above sea level and

1% for each 10° F(5.6° C) above 77° F(25° C). The engine will operate satisfactorily at

an angle up to 15°. Refer to the equipment operator’s manual for safe allowable

operating limits on slopes.

Common Service Parts n

Service Part Part Number

Oval Air Filter 790166

Fuel Additive 5041, 5058

Resistor Spark Plug 802592

Long Life Platinum Spark Plug 5062

Spark Plug Wrench 89838, 5023

Spark Tester 19368

n We recommend that you see any Briggs & Stratton Authorized Dealer for all

maintenance and service of the engine and engine parts. Use only genuine Briggs &

Stratton parts.

BRIGGS & STRATTON ENGINE OWNER WARRANTY POLICY

May 2008

Briggs & Stratton Corporation will repair or replace, free of charge, any part(s) of the engine that is defective in material or workmanship or both. Transportation charges on

product submitted for repair or replacement under this warranty must be borne by purchaser. This warranty is effective for and is subject to the time periods and conditions

stated below. For warranty service, find the nearest Authorized Service Dealer in our dealer locator map at BRIGGSandSTRATTON.COM, or by calling

1-800-233-3723, or as listed in the ‘Yellow Pagest’.

There is no other expressed warranty. Implied warranties, including those of merchantability and fitness for a particular purpose, are limited to one year from

purchase, or to the extent permitted by law and all implied warranties are excluded. Liability for incidental or consequential damages are excluded to the extent

exclusion i s permitted by law. Some states or countries do not allow limitations on how long an implied warranty lasts, and some states or countries do not allow the

exclusion or limitation of incidental or consequential damages, so the above limitation and exclusion may not apply to you. This warranty gives you specific legal rights and

you may also have other rights which vary from state to state and country to country.

LIMITED WARRANTY

STANDARD WARRANTY TERMS *

Brand/Product Type

Consumer Use Commercial Use

Vanguardt

2 years 2 years

Extended Life Seriest, I/C

, Intekt I/C

, Intekt Pro

2 years 1 year

Snow Series MAXt with Dura-Bo ret Cast Iron Sleeve

2 years 1 year

All Other Briggs & Stratton Engines 2 years 90 days

* These are our standard warranty terms, but occasionally there may be additional warranty coverage that was not determined at time of publication. For a listing of current

warranty terms for your engine, go to BRIGGSandSTRATTON.COM or contact your Authorized Briggs & Stratton Service Dealer.

Engines used on Home Standby Generator applications are warranted under consumer use only. This warranty does not apply to engines on equipment used for prime

power in place of a utility. Engines used in competitive racing or on commercial or rental tracks are not warranted.

The warranty period begins on the date of purchase by the first retail consumer or commercial end user, and continues for the period of time stated in the table above. “Consumer

use” means personal residential household use by a retail consumer. “Commercial use” means all other uses, including use for commercial, income producing or rental purposes.

Once an engine has experienced commercial use, it shall thereafter be considered as a commercial use engine for purposes of this warranty.

No warranty registration is necessary to obtain warranty on Briggs & Stratton Products. Save your proof of purchase receipt. If you do not provide proof of the initial

purchase date at the time warranty service is requested, the manufacturing date of the product will be used to determine the warranty period.

About Your Warranty

Briggs & Stratton welcomes warranty repair and apologizes to you for being

inconvenienced. Any Authorized Service Dealer may perform warranty repairs. Most

warranty repairs are handled routinely, but sometimes requests for warranty service may

not be appropriate.

If a customer differs with the decision of the Service Dealer, an investigation will be made

to determine whether the warranty applies. Ask the Service Dealer to submit all

supporting facts to his Distributor or the Factory for review. If the Distributor or the

Factory decides that the claim is justified, the customer will be fully reimbursed for those

items that are defective. To avoid misunderstanding which might occur between the

customer and the Dealer, listed below are some of the causes of engine failure that the

warranty does not cover.

Normal wear: Engines, like all mechanical devices, need periodic parts service and

replacement to perform well. Warranty will not cover repair when normal use has

exhausted the life of a part or an engine. Warranty would not apply if engine damage

occurred because of misuse, lack of routine maintenance, shipping, handling,

warehousing or improper installation. Similarly, warranty is void if the serial number of the

engine has been removed or the engine has been altered or modified.

Improper maintenance: The life of an engine depends upon the conditions under which

it operates, and the care it receives. Some app lications, such as t illers, pumps and rotary

mowers, are very often used in dusty or dirty conditions, which can cause what appears

to be premature wear. Such wear, when caused by dirt, dust, spark plug cleaning grit, or

other abrasive material that has entered the engine because of improper maintenance, is

not covered by warranty.

This warranty covers engine related defective material and/or workmanship only

and not replacement or refund of the equipment to which the engine may be

mounted. Nor does the warranty extend to repairs required because of:

1 Problems caused by parts that are not original Briggs & Stratton parts.

2 Equipment controls or installations that prevent starting, cause unsatisfactory engine

performance, or shorten engine life. (Contact equipment manufacturer.)

3 Leaking carburetors, clogged fuel pipes, sticking valves, or other damage, caused

by using contaminated or stale fuel.

4 Parts which are scored or broken because an engine was operated with insufficient

or contaminated lubricating oil, or an incorrect grade of lubricating oil (check and

refill when necessary, and change at recommended intervals). OIL GARD may not

shut down running engine. Engine damage may occur if oil level is not properly

maintained.

5 Repair or adjustment of associated parts or assemblies such as clutches,

transmissions, remote controls, etc., which are not manufactured by Briggs &

Stratton.

6 Damage or wear to parts caused by dirt, which entered the engine because of

improper air cleaner maintenance, re-assembly, or use of a non-original air cleaner

element or cartridge. At recommended intervals, clean and/or replace the filter as

stated in the Operator’s Manual.

7 Parts damaged by over-speeding, or overheating caused by grass, debris, or dirt,

which plugs or clogs the cooling fins, or flywheel area, or damage caused by

operating the engine in a confined area without sufficient ventilation. Clean engine

debris at recommended intervals as stated in the Operator’s Manual.

8 Engine or equipment parts broken by excessive vibration caused by a loose engine

mounting, loose cutter blades, unbalanced blades or loose or unbalanced impellers,

improper attachment of equipment to engine crankshaft, over-speeding or other

abuse in operation.

9 A bent or broken crankshaft, caused by stri king a solid object with the cutter blade of

a rotary lawn mower, or excessive v-belt tightness.

10 Routine tune-up or adjustment of the engine.

11 Engine or engine component failure, i.e., combustion chamber, valves, valve seats,

valve guides, or burned starter motor windings, caused by the use of alternate fuels

such as, liquified petroleum, natural gas, altered gasolines, etc.

W arranty service is available only through authorized service dealers by Briggs &

Stratton Corporation. Locate your nearest Authorized Service Dealer in our dealer

locator map on BRIGGSandSTRATTON.COM or by calling 1- 800-233-3723, or as

listed in the ‘Yellow Pagest’.

10 BRIGGSandSTRATTON.COM

Emissions Control System Warranty Statement

Briggs & Stratton Corporation (B&S), the California Air Resources Board (CARB) and the United States Environmental Protection

Agency (U.S. EPA) Emissions Control System Warranty Statement (Owner’s Defect Warranty Rights and Obligations)

California, United States and Canada Emissions Control Defects

Warranty Statement

The California Air Resources Board (CARB), U.S. EPA and B&S are pleased to explain

the Emissions Control System Warranty on your small off-road engine (SORE). In

California, new small off-road engines model year 2006 and later must be designed, built

and equipped to meet the State’s stringent anti-smog standards. Elsewhere in the United

States, new non-road, spark-ignition engines certified for model year 1997 and later must

meet similar standards set forth by the U.S. EPA. B&S must warrant the emissions

control system on your engine for t he periods of time listed below, provided there has

been no abuse, neglect or improper maintenance of your small off-road engine.

Your emissions control system includes parts such as the carburetor, air cleaner, ignition

system, fuel line, muffler and catalytic converter. Also included may be connectors and

other emissions related assemblies.

Where a warrantable condition exists, B&S will repair your small off-road engine at no

cost to you including diagnosis, parts and labor.

Briggs & Stratton Emissions Control Defects Warranty Coverage

Small off-road engines are warranted relative to emissions control parts defects for a

period of two years, subject to provisions set forth below. If any covered part on your

engine is defective, the part will be repaired or replaced by B&S.

Owner’s Warranty Responsibilities

As the small off-road engine owner, you are responsible for the performance of the

required maintenance listed in y our Operating and Maintenance Instructions. B&S

recommends that you retain all your receipts covering maintenance on your small

off-road engine, but B&S cannot deny warranty solely for the lack of receipts or f or your

failure to ensure the performance of all scheduled maintenance.

As the small off-road engine owner, you should however be aware that B&S may deny

you warranty coverage if your small off-road engine or a part has failed due to abuse,

neglect, improper maintenance or unapproved modifications.

You are responsible for presenting your small off-road engine to an Authorized B&S

Service Dealer as soon as a problem exists . The undisputed warranty repairs should be

completed in a reasonable amount of time, not to exceed 30 days.

If you have any questions regarding your warranty rights and responsibilities, you should

contact a B&S Service Representative at (414) 259-5262.

The emissions warranty is a defects warranty. Defects are judged on normal engine

performance. The warranty is not related to an in-use emissions test.

Briggs & Stratton Emissions Control Defects Warranty Provisions

The following are specific provisions relative to your Emissions Control Defects Warranty Coverage. It is in addition to the B&S engine warranty for non-regulated engines found in the

Operating and Maintenance Instructions.

1. Warranted Parts

Coverage under this warranty extends only to the parts listed below (the emissions

control systems parts) t o t he extent these parts were present on the engine

purchased.

a. Fuel Metering System

• Cold start enrichment system (soft choke)

• Carburetor and internal parts

• Fuel pump

• Fuel line, fuel line fittings, clamps

• Fuel tank, cap and tether

• Carbon canister

b. Air Induction System

• Air cleaner

• Intake manifold

• Purge and vent line

c. Ignition System

• Spark plug(s)

• Magneto ignition system

d. Catalyst System

• Catalytic converter

• Exhaust manifold

• Air injection system or pulse valve

e. Miscellaneous Items Used in Above Systems

• Vacuum, temperature, position, time sensitive valves and switches

• Connectors and assemblies

2. Length of Coverage

B&S warrants to the initial owner and each subsequent purchaser that the W arranted

Parts shall be free from defects in materials and workmanship which caused the

failure of the Warranted Parts for a period of two years from the date the engine is

delivered to a retail purchaser.

3. No Charge

Repair or replacement of any Warranted Part will be performed at no charge to the

owner, including diagnostic labor which leads to the determination that a Warranted

Part is defective, if the diagnostic work is performed at an Authorized B&S Service

Dealer. For emissions warranty service contact your nearest Authorized B&S

Service Dealer as listed in the “Yellow Pages” under “Engines, Gasoline,” “Gasoline

Engines,” “Lawn Mowers,” or similar category.

4. Claims and Coverage Exclusions

Warranty claims shall be filed in accordance with the provisions of the B&S Engine

Warranty Policy. Warranty coverage shall be excluded for failures of Warranted

Parts which are not original B&S parts or because of abuse, neglect or improper

maintenance as set forth in the B&S Engine Warranty Policy. B&S is not liable to

cover failures of Warranted Parts caused by the use of add -on, non-original, or

modified parts.

5. Maintenance

Any Warranted Part which is not scheduled for replacement as required

maintenance or which is scheduled only for regular inspection to the effect of “repair

or replace as necessary” shall be warranted as to defects for the warranty period.

Any Warranted Part which is scheduled for replacement as required maintenance

shall be warranted as to defects only for the period of time up to the first scheduled

replacement for that part. Any replacement part that is equivalent in performance

and durability may be used in the performance of any maintenance or repairs. The

owner is responsible for the performance of all required maintenance, as defined in

the B&S Operating and Maintenance Instructions.

6. Consequential Coverage

Coverage hereunder shall extend to the failure of any engine components caused

by the failure of any Warranted Part still under warranty.

Look For Relevant Emissions Durability Period and Air Index Information On Your Engine Emissions Label

Engines that are certified to meet the California Air Resources Board (CARB) Emissions

Standard must display information regarding the Emissions Durability Period and the Air

Index. Briggs & Stratton makes this information available to the consumer on our

emissions labels. The engine emissions label will indicate certification information.

The Emissions Durability Period describes the number of hours of actual running time

for which the engine is certified to be emissions compliant, assuming proper

maintenance in accordance with the Oper ating & Maintenance I nstructions. The

following categories are used:

Moderate:

Engine is certified to be emissions compliant for 125 hours of actual engine running time.

Intermediate:

Engine is certified to be emissions compliant for 250 hours of actual engine running time.

Extended:

Engine is certified to be emissions compliant for 500 hours of actual engine running time.

For example, a typical walk-behind lawn mower is used 20 to 25 hours per year.

Therefore, the Emissions Durability Period of an engine with an intermediate rating

would equate to 10 to 12 years.

Briggs & Stratton engines are certified to meet the United States Environmental

Protection Agency (USEPA) Phase 2 emissions standards. For Phase 2 certified

engines, the Emissions Compliance Period referred to on the Emissions Compliance

label indicates the number of operating hours for which t he engine has been shown to

meet Federal emissions requirements.

For engines less than 225 cc displacement.

Category C = 125 hours , Category B = 250 hours , Category A = 500 hours

For engines of 225 cc or more displacement.

Category C = 250 hours , Category B = 500 hours , Category A = 1000 hours

Îáùè ñâåäåíèÿ

Çà ˜åçå˜âíè …àñòè èëè òåõíè…åñêà ïîìîù çàïèμåòå ïî-äîëó íîìå˜àòà íà ìîäåëà,

òèïà è êîäà íà äâèãàòåë âè, çàåäíî ñ äàòàòà íà êóïóâàíåòî. ‚åçè íîìå˜à ñå

íàìè˜àò âú˜õó äâèãàòåë âè (âè¥òå ñò˜àíèöàòà Ïîêàçàòåëè è óïðàâëåíèÿ).

Äàòà íà êóïóâàíå:

Ìîäåë íà äâèãàòåëÿ:

MM/ÄÄ/øøøø

ﬂîäåë: ÿîä:‚èï:

Èíôîðìàöèÿ çà íîìèíàëíàòà ìîùíîñò íà äâèãàòåëèòå

ﬁúëíàòà ìîùíîñò âú˜õó îòäåëíèòå ìîäåëè áåíçèíîâè äâèãàòåëè å îòáåëçàíà â

ñúîòâåòñòâèå ñúñ ñúçäàäåíè îò SAE (Ä˜ó¥åñòâî íà èí¥åíå˜èòå îò

àâòîìîáèëíàòà ï˜îìèμëåíîñò è ò˜àíñïî˜òà) ﬁ˜àâèëíèê çà òåõíè…åñêà

åêñïëîàòàöè J1940 (ﬂåòîäèêà çà îï˜åäåëíå íà íîìèíàëíàòà ìîùíîñò è

âú˜òùè ìîìåíò íà ìàëêè äâèãàòåëè), à íîìèíàëíàòà èì ìîùíîñò áå ïîëó…åíà è

êî˜èãè˜àíà â ñúîòâåòñòâèå ñ âå˜ñèòà íà ﬁ˜àâèëíèêà çà òåõíè…åñêà

åêñïëîàòàöè J1995 íà SAE (ˆåäàêöè îò 2002-05 ã.). Ñòîéíîñòèòå íà âú˜òùè

ìîìåíò ñà èçâåäåíè ï˜è 3060 îá/ìèí.; ñòîéíîñòèòå íà ìîùíîñòòà √ ï˜è 3600

îá/ìèí. Äåéñòâèòåëíàòà ïúëíà ìîùíîñò íà äâèãàòåëèòå ùå áúäå ïî-íèñêà è ñå

âëèå, ìå¥äó ä˜óãîòî, îò îêîëíàòà ñ˜åäà, â êîòî îáî˜óäâàíåòî ñå åêñïëîàòè˜à è

îò õà˜àêòå˜èñòèêèòå íà âñåêè îòäåëåí äâèãàòåë. ﬁ˜è μè˜îêè íàáî˜ îò ìàμèíè,

âú˜õó êîèòî ñå ïîñòàâò äâèãàòåëèòå è ï˜è ˜àçíîîá˜àçèåòî íà åêîëîãè…íèòå

èçèñêâàíè,âêîòî îáî˜óäâàíåòî ˜àáîòè, áåíçèíîâèò äâèãàòåë íìà äà ˜àçâèå

óêàçàíàòà îò ï˜îèçâîäèòåë ïúëíà ìîùíîñò, êîãàòî å ìîíòè˜àí íà äàäåíî

åíå˜ãèéíî îáî˜óäâàíå (äåéñòâèòåëíàòà ìîùíîñò ∆íà îáåêòà∆ èëè åôåêòèâíàòà

ìîùíîñò). ‚àçè ˜àçëèêà ñå äúë¥è íà ãîëì á˜îé ôàêòî˜è, âêë˚…èòåëíî íà

àêñåñîà˜èòå êúì äâèãàòåë (âúçäóμåí ôèëòú˜, àóñïóõ, ñèñòåìà çà çà˜å¥äàíå,

ñèñòåìà çà îõëà¥äàíå, êà˜áó˜àòî˜, ãî˜èâíà ïîìïà è ò. í.), íà õà˜àêòå˜íèòå

îã˜àíè…åíè çà èçïîëçâàíåòî ìó, íà óñëîâèòà â îêîëíàòà ñ˜åäà, â êîòî

äâèãàòåëò ˜àáîòè (òåìïå˜àòó˜à, âëà¥íîñò, íàäìî˜ñêà âèñî…èíà), íà ˜àçëè…è

òà

âúâ âñåêè îòäåëåí äâèãàòåë. ﬁî˜àäè òåõíîëîãè…íè è ï˜îèçâîäñòâåíè îã˜àíè…åíè

ôè˜ìàòà Briggs & Stratton ìî¥å äà çàìåñòè äàäåí äâèãàòåë ñ ïî-âèñîêà

íîìèíàëíà ìîùíîñò ñ äâèãàòåë îò òåçè ñå˜èè.

Òåõíèêà çà áåçîïàñíîñò íà îïåðàòîðà

Âçðèâîîïàñíî

Îòðîâíè

ãàçîâå

Äâèæåùè

ñå ÷àñòè

Îïàñíîñò çà ïîðàæåíèÿ

îò åëåêòðè÷åñêè òîê

Ãîðåùà

ïîâúðõíîñò

Îáðàòåí

óäàð

Îãíåîïàñíî

Ïðåêðàòÿâàíå

ïîäàâàíåòî íà ãîðèâî

Ïðî÷åòåòå

Ðúêîâîäñòâîòî

Ñìóêà÷

Ìàñëî

Ãîðèâî

Âêë. Èçêë.

Ñòîï

Äà ñå íîñÿò

ïðåäïàçíè î÷èëà

Áúðçè

îáîðîòè

Áàâíè

îáîðîòè

ÑÈÌÂÎËÈ ÇÀ ÁÅÇÎÏÀÑÍÎÑÒ È ÓÏÐÀÂËÅÍÈÅ

Îïàñíè

õèìèêàëè

èçìðúçâàíåòî

ﬁ˜åäóï˜åäèòåëíèò ñèìâîë çà îïàñíîñò

îï˜åäåë ï˜åäîõ˜àíèòåëíà

èíôî˜ìàöè çà ˜èñêîâå, êîèòî ìîãàò äà äîâåäàò äî íà˜àíâàíå íà ïå˜ñîíàëà.

Ñèãíàëèçè˜àùà äóìà (›ﬁæÑ‹›, ﬁˆÅÄ‡ﬁˆÅ≠ÄÅ‹¤Å èëè ◊‹¤ﬂæ‹¤Å) ñå ïîñòàâ

çàåäíî ñ ï˜åäóï˜åäèòåëåí ñèìâîë, çà äà ïîñî…è âå˜îòíîñòòà è ïîòåíöèàëíàòà

ñå˜èîçíîñò íà íà˜àíâàíåòî. Äîïúëíèòåëíî, åäèí ñèìâîë çà îïàñíîñò ìî¥å äà

ïîêàçâà âèäà íà îïàñíîñòòà.

ÎÏÀÑÍÎ ïîñî…âà îïàñíîñò, êîòî, àêî íå áúäå èçáåãíàòà, ùå äîâåäå

äî ñìúðò èëè ñåðèîçíî íàðàíÿâàíå.

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ ïîñî…âà îïàñíîñò, êîòî, àêî íå áúäå

èçáåãíàòà, ìîæå äà äîâåäå äî ñìúðò èëè ñåðèîçíî íàðàíÿâàíå.

ÂÍÈÌÀÍÈÅ ïîñî…âà îïàñíîñò, êîòî àêî íå áúäå èçáåãíàòà, ìîæå äà

äîâåäå äî ìàëêà èëè ñðåäíà ñòåïåí íà íàðàíÿâàíå.

ÂÍÈÌÀÍÈÅ, èçïîëçâàíî áåç ï˜åäóï˜åäèòåëíè ñèìâîë, ïîñî…âà

ñèòóàöè,êîòî áè ìîãëà äà äîâåäå äî ïîâðåæäàíå íà ïðîäóêòà.

¤çãî˜åëèòå ãàçîâå îò òîçè äâèãàòåë ñúäú˜¥àò õèìè…åñêè ñúåäèíåíè,

èçâåñòíè íà ùàòà ÿàëèôî˜íè êàòî ï˜è…èíèòåëè íà ˜àê, óâ˜å¥äàíè ï˜è

˜à¥äàíå, èëè ä˜óãè óâ˜å¥äàíè, ñâú˜çàíè ñ ˜åï˜îäóêòèâíîñòòà.

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

ÿî˜ïî˜àöè Briggs & Stratton íå îäîá˜âàèíåïîçâîëâà èçïîëçâàíåòî íà

òåçè äâèãàòåëè âú˜õó âñúäåõîäè íà 3 êîëåëà (ATVs), ìîòîöèêëåòè,

óâåñåëèòåëíè êîëè…êè/çà êà˜òèíã, ëåòàòåëíè àïà˜àòè èëè ò˜àíñïî˜òíè

ñ˜åäñòâà çà ó…àñòèå â ñ úñòåçàòåëíè ìå˜îï˜èòè. ¤çïîëçâàíåòî íà òåçè

äâèãàòåëè íà òàêèâà ìàμèíè ìî¥å äà äîâåäå äî ìàòå˜èàëíè ùåòè,

ñå˜èîçíè íà˜àíâàíè (âêë˚…èòåëíî ïà˜àëèçà) è äî˜è äî ñìú˜ò.

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

ÂÍÈÌÀÍÈÅ: ‹àñòîùèò äâèãàòåë ñå äîñòàâ îò Briggs & Stratton áåç ìàñëî.

ﬁ˜åäè äà ñòà˜òè˜àòå äâèãàòåë ñå óâå˜åòå, …å ñòå íàëåëè ìàñëî ñïî˜åä

èíñò˜óêöèèòå â òîâà ˜úêîâîäñòâî. æêî ãî ñòà˜òè˜àòå áåç ìàñëî, òîé ùå ñå

ïîâ˜åäè, áåç äà ìî¥å äà áúäå ïîï˜àâåí è ãà˜àíöèòà íìà äà ãî ïîê˜èâà.

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

Áåíçèíúò è íåãîâèòå ïàðè ñà èçêëþ÷èòåëíî îãíåîïàñíè è

èçáóõëèâè.

Ïîæàð èëè âçðèâ ìîãàò äà ïðè÷èíÿò ñåðèîçíè îáãàðÿíèÿ èëè ñìúðò.

Ïðè äîëèâàíå íà ãîðèâî

• ¤çêë˚…åòå äâèãàòåë è ãî îñòàâåòå äà ñå îõëàäè íàé-ìàëêî 2 ìèíóòè, ï˜åäè

äà ñâàëèòå êàïà…êàòà íà ˜åçå˜âîà˜à çà ãî˜èâî.

• ﬁúëíåòå ˜åçå˜âîà˜à çà ãî˜èâî íà îòê˜èòî èëè â äîá˜å âåíòèëè˜àíî

ïîìåùåíèå.

• ‹å ï˜åïúëâàéòå ˜åçå˜âîà˜à çà ãî˜èâî. ﬁúëíåòå ãî ï˜èáëèçèòåëíî 1,5 èí…à

(38 mm) ïî-íèñêî îò ãî˜íè ˜úá íà ãú˜ëîâèíàòà, çà äà ïîçâîëèòå ˜àçμè˜åíèå

íà ãî˜èâîòî.

• Ä˜ú¥òå áåíçèíà äàëå… îò èñê˜è, îòê˜èòè ïëàìúöè, ñèãíàëíè ëàìïè, òîïëèíà

è ä˜óãè çàïàëèòåëíè èçòî…íèöè.

• ﬁ˜îâå˜âàéòå …åñòî ãî˜èâîï˜îâîäèòå, ˜åçå˜âîà˜à, êàïà…êàòà è

ñúåäèíåíèòà çà ïóêíàòèíè è òå…îâå. Çàìåíéòå ãè àêî å íåîáõîäèìî.

• æêî ãî˜èâîòî ñ å ˜àçëåå, èç…àêàéòå äîêàòî òî ñå èçïà˜è, ï˜åäè äà ñòà˜òè˜àòå

äâèãàòåë.

Ïðè ñòàðòèðàíå íà äâèãàòåëÿ

• ‡âå˜åòå ñå, …å çàïàëèòåëíàòà ñâåù, μóìîçàãëóμèòåë, êàïà…êàòà íà

˜åçå˜âîà˜à çà ãî˜èâî è âúçäóμíè ôèëòú˜ (àêî èìà òàêúâ) ñà íà ìñòîòî ñè è

ñà îáåçîïàñåíè.

• ‹å ˜àçâú˜òàéòå äâèãàòåë ñ èçâàäåíà çàïàëèòåëíà ñâåù.

• æêî äâèãàòåëò ñå çàäàâè, ïîñòàâåòå ñìóêà…à (àêî èìà òàêúâ) íà ïîçèöè

OPEN/RUN, ï˜åìåñòåòå ˜ú…íàòà ãàç (àêî èìà ò àêàâà) íà ïîçèöè FAST è

˜àçâú˜òàéòå, äîêàòî äâèãàòåëò ñòà˜òè˜à.

Ïðè ðàáîòåùà ìàøèíà

• ‹å íàêëàíéòå äâèãàòåë èëè ìàμèíàòà ïîä úãúë, êîéòî âîäè äî ˜àçëèâàíå íà

áåíçèíà.

• ‹å çàïóμâàéòå êà˜áó˜àòî˜à, çà äà ñï˜åòå äâèãàòåë.

• ‹èêîãà íå ñòà˜òè˜àéòå è íå ˜àáîòåòå ñ äâèãàòåë, íà êîéòî âúçäóμíè

ôèëòú˜åí (àêî èìà òàêúâ) êîìïëåêò å ñâàëåí.

Êîãàòî ñìåíÿâàòå ìàñëîòî

•

æêî èçòî…âàòå ìàñëîòî ï˜åç ãî˜íàòà ò˜úáà çà íàëèâàíå, ˜åçå˜âîà˜úò çà

ãî˜èâîòî ò˜áâà äà áúäå ï˜àçåí, çàùîòî â ï˜îòèâåí ñëó…àé ìî¥å äà èìà òå…

íà ãî˜èâî, âîäåù äî ïî¥à˜ èëè åêñïëîçè.

Ïðè òðàíñïîðòèðàíå íà ìàøèíàòà

• ‚˜àíñïî˜òè˜àéòå ñ ﬁˆæÇÅ‹ ˜åçå˜âîà˜, èëè ñ ê˜àí çà ïîäàâàíå íà ãî˜èâî íà

ïîçèöè OFF.

Êîãàòî ñêëàäèðàòå áåíçèí èëè îáîðóäâàíå ñ ãîðèâî â ðåçåðâîàðà

• Ñêëàäè˜àéòå äàëå… îò ïåùè, ïå…êè, âîäîíàã˜åâàòåëè èëè ä˜óãè åëåêò˜è…åñêè

ï˜èáî˜è, êîèòî èìàò ñèãíàëíà ëàìïà èëè ä˜óã çàïàëèòåëåí èçòî…íèê, çàùîòî

òå ìîãàò äà âúçïëàìåíò áåíçèíîâèòå ïà˜è.

12 BRIGGSandSTRATTON.COM

Ïóñêàíåòî íà äâèãàòåëÿ ñúçäàâà èñêðåíå.

Èñêðåíåòî ìîæå äà âúçïëàìåíè íàìèðàùèòå ñå íàîêîëî çàïàëèìè

ãàçîâå.

Òîâà ìîæå äà äîâåäå äî åêñïëîçèÿ è ïîæàð.

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

• æêî èìà èçòè…àíå íà ï˜è˜îäåí èëè âòå…íåí ãàç ï˜îïàí â ïîìåùåíèåòî, íå

ñòà˜òè˜àéòå äâèãàòåë.

• ‹å èçïîëçâàéòå ãî˜èâà çà íà…àëíî çàïàëâàíå ïîä íàëãàíå, çàùîòî ïà˜èòå èì

ñà çàïàëèòåëíè.

Äâèãàòåëèòå èçïóñêàò âúãëåðîäåí îêèñ, êîéòî å îòðîâåí ãàç, áåç

ìèðèñ è öâÿò.

Âäèøâàíåòî íà âúãëåðîäåí îêèñ ìîæå äà ïðè÷èíè ãàäåíå,

ïðèïàäúê èëè ñìúðò.

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

• Ñòà˜òè˜àéòå è ˜àáîòåòå ñ äâèãàòåë íàâúí.

• ‹å ñòà˜òè˜àéòå è íå ˜àáîòåòå ñ äâèãàòåë â çàòâî˜åíî ïîìåùåíèå, äî˜è è ï˜è

îòâî˜åíè â˜àòè èëè ï˜îçî˜öè.

Áúðçîòî îòòåãëÿíå íà ïóñêîâîòî âúæå (îáðàòåí óäàð) ùå ïðèäúðïà

èçöÿëî ðúêàòà âè êúì äâèãàòåëÿ ïî-áúðçî, îòêîëêîòî âèå ìîæåòå äà

ÿ îòäðúïíåòå.

Òîâà ìîæå äà ïðè÷èíè ñ÷óïåíè êîñòè, ôðàêòóðè, êîíòóçèè è

íàâÿõâàíèÿ.

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

• ÿîãàòî ñòà˜òè˜àòå äâèãàòåë, èçòåãëåòå áàâíî âú¥åòî íà ñòà˜òå˜à, äîêàòî

óñåòèòå ñúï˜îòèâëåíèå, à ïîñëå ˜çêî ä˜úïíåòå, çà äà èçáåãíåòå îá˜àòíè

óäà˜.

• ¤çêë˚…åòå âñêî âúíμíî îáî˜óäâàíå/çàäâè¥âàíî îò äâèãàòåë, ï˜åäè äà ãî

ñòà˜òè˜àòå.

• Äè˜åêòíî ï˜èêà…åíèòå êúì äâèãàòåë ìàμèííè åëåìåíòè êàòî íî¥îâå, ïå˜êè,

ëåáåäêè, çúáíè êîëåëà, çàäâè¥âàùè âå˜èãè è ä˜óãè, ò˜áâà äà áúäàò ñèãó˜íî

ï˜èê˜åïåíè.

Âúðòÿùèòå ñå ÷àñòè ìîãàò äà äîïðà ò èëè çàõâàíàò ðúöå, êðàêà,

êîñà, îáëåêëî èëè ïðèíàäëåæíîñòè.

Ìîæå äà ñå äîñòèãíå äî òðàâìàòè÷íà àìïóòàöèÿ èëè ñåðèîçíî

íàðàíÿâàíå.

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

• ˆàáîòåòå ñ äâèãàòåë ï˜è ïîñòàâåíè çàùèòíè êàïàöè.

• Ä˜ú¥òå ˜úöåòå è ê˜àêàòà ñè äàëå… îò âú˜òùè ñå …àñòè.

• ﬁ˜èâú˜çâàéòå äúëãèòå êîñè è ñâàëéòå óê˜àμåíèòà.

• ‹å íîñåòå ïî ñåáå ñè μè˜îêî îáëåêëî, âèñùè μíó˜îâå èëè âåùè, êîèòî ìîãàò

äà áúäàò çàõâàíàòè.

Ðàáîòåùèòå äâèãàòåëè îòäåëÿò òîïëèíà. ×àñòèòå íà äâèãàòåëèòå,

îñîáåíî øóìîçàãëóøèòåëÿ, ñòàâàò èçêëþ÷èòåëíî ãîðåùè.

Ïðè äîïèð ìîæå äà ïîëó÷èòå ñåðèîçíî èçãàðÿíå.

Ãîðèìèòå îòïàäúöè, êàòî ëèñòà, òðåâè, õðàñòàëàê è äðóãè, ìîãàò äà

ñå çàïàëÿò.

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

• ›ñòàâåòå μóìîçàãëóμèòåë, öèëèíäú˜à íà äâèãàòåë è ˜åá˜àòà äà ñå

îõëàäò, ï˜åäè äà ãè äîêîñâàòå.

• ›òñò˜àíåòå íàò˜óïàíèòå îòëîìêè îêîëî μóìîçàãëóμèòåë è öèëèíäú˜à.

• ﬂîíòè˜àéòå è ïîääú˜¥àéòå â ˜àáîòíî ñúñòîíèå èñê˜îãàñèòåë, ï˜åäè äà

èçïîëçâàòå äâèãàòåë íà çàëåñåíè ìåñòà, ç àò˜åâåíè ïëîùè, ïëîùè ñ õ˜àñòè è

íåîá˜àáîòåíè ìåñòà. Âàòúò ÿàëèôî˜íè èçèñêâà òîâà (â ˆàçäåë 4442 íà

ÿàëèôî˜íèéñêè ï˜àâèëíèê çà îáùåñòâåíè ˜åñó˜ñè). ◊úçìî¥íîåä˜óãèùàòè

äà èìàò ïîäîáíè çàêîíè. ·åäå˜àëíèòå çàêîíè ñå ï˜èëàãàò íà ôåäå˜àëíà

òå˜èòî˜è.

Ñëó÷àéíî èñêðåíå ìîæå äà äîâåäå äî ïîæàð èëè ïîðàçÿâàíå îò

åëåêòðè÷åñêè òîê.

Íåâîëíî ñòàðòèðàíå ìîæå äà äîâåäå äî çàõâàùàíå, òðàâìàòè÷íà

àìïóòàöèÿ èëè äî ðàíÿâàíå.

Îïàñíîñò îò ïîæàð

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

Ïðåäè èçâúðøâàíå íà íàñòðîéêè è ïîïðàâêè:

• ›òêà…åòå êàáåëà íà çàïàëèòåëíàòà ñâåù è ãî ä˜ú¥òå äàëå… îò íå.

• ›òêà…åòå ìèíóñ-êëåìàòà íà àêóìóëàòî˜à (ñàìî ï˜è äâèãàòåëè ñ åëåêò˜è…åñêè

ñòà˜òå˜).

• ¤çïîëçâàéòå ñàìî ïîäõîäùè èíñò˜óìåíòè.

• ‹å çàñòîïî˜âàéòå ëîñòîâèòå ñèñòåìè ñ ˜åãóëè˜àùàòà ï˜ó¥èíà, èëè ñ ä˜óãè

…àñòè, çà äà ïîâèμèòå îáî˜îòèòå íà äâèãàòåë.

• ˆåçå˜âíèòå …àñòè ò˜áâà äà áúäàò ñúñ ñúùîòî êà…åñòâî è äà ñå ìîíòè˜àò â

ñúùàòà ïîçèöè, êàêòî î˜èãèíàëíèòå …àñòè.

• ‹å óä˜éòå ìàõîâèêà ñ …óê èëè òâú˜ä ï˜åäìåò, çàùîòî òîé ìî¥å äà ñå ñò˜îμè

ïî â˜åìå íà ˜àáîòà.

Ïðè èçïðîáâàíå çà èñêðà:

• ¤çïîëçâàéòå îäîá˜åí òèï òåñòå˜ çà ñâåùè.

• ‹å ï˜àâåòå ï˜îâå˜êà çà èñê˜à ï˜è èçâàäåíà çàïàëèòåëíà ñâåù.

Åëåìåíòè è óïðàâëåíèÿ

Ñ˜àâíåòå èë˚ñò˜àöèòà

ñâàμè äâèãàòåë, çà äà ñå çàïîçíàåòå ñ

˜àçïîëî¥åíèåòî íà ˜àçëè…íèòå åëåìåíòè è óï˜àâëåíè.

A. ¤äåíòèôèêàöè íà äâèãàòåë

Ìîäåë Òèï Êîä

B. Çàïàëèòåëíà ñâåù

C. ◊úçäóμåí ôèëòú˜

D. Ñìóêà…

E. ˆúêîõâàòêà íà âú¥åòî çà ˜ú…íè ñòà˜òå˜

F. ﬁ˜åäïàçèòåë çà ï˜úñòèòå

G. ˆú…íà ãàç (ïî îïöè)

H. Ñòîï-êë˚… (ïî îïöè)

I. ˆåçå˜âîà˜ çà ãî˜èâî è êàïà…êà

J. ﬁ˜îáêà çà èçòî…âàíå íà ìàñëîòî

K. ›òâî˜ çà íàëèâàíå íà ìàñëî

L. Æóìîçàãëóμèòåë

ÿî¥óõ íà μóìîçàãëóμèòåë (ïî îïöè)

¤ñê˜îãàñèòåë (ïî îïöè)

M. Çúáíà ˜åäóêòî˜íà êóòè (ïî îïöè)

Ðàáîòà

◊ìåñòèìîñò çà ìàñëî (íàï˜àâåòå ñï˜àâêà â ˜àçäåë Òåõíè÷åñêè äàííè).

Ïðåïîðúêè çà ìàñëîòî

Çà ïîëó…àâàíå íà íàé-äîá˜è òåõíè…åñêè ïîêàçàòåëè ï˜åïî˜ú…âàìå èçïîëçâàíåòî

íà ìàñëàòà íà Briggs & Stratton ñ ãà˜àíöè è ñå˜òèôèêàò çà êà…åñòâî. Ä˜óãè

âèñîêîêà…åñòâåíè ìàñëà ñ ìèåùè ï˜èñàäêè ñà ï˜èåìëèâè, àêî ñà êëàñèôèöè˜àíè

çà ˜àáîòíè ˜å¥èìè SF, SG, SH, SJ èëè ïî-âèñîêè. Äà íå ñå èçïîëçâàò ñïåöèàëíè

äîáàâêè.

◊úíμíèòå òåìïå˜àòó˜è îï˜åäåëò ï˜àâèëíè âèñêîçèòåò íà ìàñëîòî çà

äâèãàòåë. ¤çïîëçâàéòå ò àáëèöàòà, çà äà èçáå˜åòå íàé-äîá˜è âèñêîçèòåò çà

î…àêâàíè äèàïàçîí íà âúíμíèòå òåìïå˜àòó˜è.

SAE 30.

10W-30

Ñèíòåòè÷íî 5W-30

5W-30

°F °C

* ¤çïîëçâàíåòî íà ì àñëî SAE 30 ï˜è òåìïå˜àòó˜è ïîä 40 ° F(4°C) ùå äîâåäå äî

ò˜óäíî ñòà˜òè˜àíå íà äâèãàòåë.

** ¤çïîëçâàíåòî íà ìàñëî 10 W-30 ï˜è òåìïå˜àòó˜è íàä 80°F(27°C) ìî¥å äà

ïîâèμè êîíñóìàöèòà íà ìàñëî. ﬁ˜îâå˜âàéòå ïî-…åñòî íèâîòî ìó.

Êàê äà ïðîâåðÿâàòå/äîëèâàòå ìàñëî - Ôèãóðà

Ïðåäè íàëèâàíå èëè ïðîâåðÿâàíå íà ìàñëîòî

• ˆàçïîëî¥åòå õî˜èçîíòàëíî äâèãàòåë.

• ﬁî…èñòåòå ìñòîòî îêîëî îòâî˜à çà íàëèâàíå íà ìàñëî îò íàñëîâàíè.

1. Ñâàëåòå êàïà…êàòà íà îòâî˜à çà íàëèâàíå íà ìàñëî (A,·èãó˜à2).

2. Çà äà äîïúëíèòå ñ ìàñëî, íàëåéòå ãî âíèìàòåëíî â äâèãàòåë ï˜åç îòâî˜à çà

ïúëíåíå (B). ‹àïúëíåòå äî òî…êàòà íà ï˜åëèâàíå.

3. ﬁîñòàâåòå íà ìñòîòî è çàòåãíåòå êàïà…êàòà íà îòâî˜à çà ïúëíåíå ñ ìàñëî.

Ïðåïîðúêè çà ãîðèâîòî

Ãîðèâîòî òðÿáâà äà îòãîâàðÿ íà ñëåäíèòå èçèñêâàíèÿ:

• ˝èñò, ï˜åñåí, áåçîëîâåí áåíçèí.

• ﬂèíèìàëíî îêòàíîâî …èñëî îò 87/87 AKI (91 RON). Çà ãîëìà íàäìî˜ñêà

âèñî…èíà, âè¥òå ïî-äîëó.

• Ÿåíçèí ñúñ ñ úäú˜¥àíèå íà íå ïîâå…å îò 10% åòàíîë (áåíç îñïè˜ò) èëè äî

15% MTBE (ò˜è-ìåòèë áóòèëîâ åòå˜) å ï˜èåìëèâ.

ÂÍÈÌÀÍÈÅ: ‹å èçïîëçâàéòå íåîäîá˜åíè áåíçèíè êàòî E85. ‹å ñìåñâàéòå

áåíçèíà ñ ìàñëî, íå ãî ìîäèôèöè˜àéòå çà ˜àáîòà ñ àëòå˜íàòèâíè ãî˜èâà. ‚îâà ùå

ïîâ˜åäè êîìïîíåíòèòå íà äâèãàòåë è ùå àíóëèðà ãàðàíöèÿòà ìó.

Çà äà ï˜åäïàçèòå ãî˜èâíàòà ñèñòåìà îò îá˜àçóâàíå íà ñìîëè, äîáàâåòå

ñòàáèëèçàòî˜ â ãî˜èâîòî. ‹àï˜àâåòå ñï˜àâêà â Ñêëàäèðàíå. øî˜èâàòà íå ñà åäíè

ñúùè. æêî íàñòúïè ï˜îáëåì ñúñ ñòà˜òè˜àíåòî èëè òåõíè…åñêèòå ïîêàçàòåëè,

ñìåíåòå äîñòàâ…èöèòå èëè ìà˜êèòå íà ãî˜èâîòî. ‹àñòîùèòäâèãàòåëèìà

ñå˜òèôèêàò çà ˜àáîòà ñ áåíçèí. Ñèñòåìàòà çà áî˜áà ñ â˜åäíèòå åìèñèè çà òîçè

äâèãàòåë å EM (ﬂîäèôèêàöèè íà äâèãàòåëèòå).

Ãîëÿìà íàäìîðñêà âèñî÷èíà

ﬁ˜è íàäìî˜ñêè âèñî…èíè íàä 5000 ôóòà (1524 ìåò˜à), áåíçèí ñ ìèíèìàëíî

îêòàíîâî …èñëî 85/85 AKI (89 RON), å ï˜èåìëèâ. Çà äà îñòàíå ñúâìåñòèì ñ

èçèñêâàíèòà çà íèâîòî íà åìèñèèòå, ñå íàëàãà íàñò˜îéêà íà äâèãàòåë â

ñúîòâåòñòâèå ñ ãîëìàòà íàäìî˜ñêà âèñî…èíà. ˆàáîòàòà áåç òàêàâà íàñò˜îéêà ùå

äîâåäå äî ïîíè¥àâàíå íà òåõíè…åñêèòå ïîêàçàòåëè, ïîâèμàâàíå íà

êîíñóìàöèòà íà ãî˜èâî è óâåëè…åíè â˜åäíè åìèñèè. ‹àï˜àâåòå ñï˜àâêà ï˜è

‡ïúëíîìîùåí ï˜åäñòàâèòåë íà Briggs & Stratton çà ñâåäåíè îòíîñíî íàñò˜îéêàòà

çà ãîëìà íàäìî˜ñêà âèñî…èíà.

‹å ñå ï˜åïî˜ú…âà ˜àáîòà íà äâèãàòåë ñ ˜åãóëè˜àù êîìïëåêò çà ãîëìà

íàäìî˜ñêà âèñî…èíà ï˜è âèñî…èíè ïîä 2500 ôóòà (762 ìåò˜à).

Êàê äà íàëèâàìå ãîðèâî - Ôèãóðà

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

Áåíçèíúò è íåãîâèòå ïàðè ñà èçêëþ÷èòåëíî îãíåîïàñíè è

èçáóõëèâè.

Ïîæàð èëè âçðèâ ìîãàò äà ïðè÷èíÿò ñåðèîçíè îáãàðÿíèÿ èëè ñìúðò.

Ïðè äîëèâàíå íà ãîðèâî

• ¤çêë˚…åòå äâèãàòåë è ãî îñòàâåòå äà ñå îõëàäè íàé-ìàëêî 2 ìèíóòè, ï˜åäè

äà ñâàëèòå êàïà…êàòà íà ˜åçå˜âîà˜à çà ãî˜èâî.

• ﬁúëíåòå ˜åçå˜âîà˜à çà ãî˜èâî íà îòê˜èòî èëè â äîá˜å âåíòèëè˜àíî

ïîìåùåíèå.

• ‹å ï˜åïúëâàéòå ˜åçå˜âîà˜à çà ãî˜èâî. ﬁúëíåòå ãî ï˜èáëèçèòåëíî 1,5 èí…à

(38 mm) ïî-íèñêî îò ãî˜íè ˜úá íà ãú˜ëîâèíàòà, çà äà ïîçâîëèòå ˜àçμè˜åíèå

íà ãî˜èâîòî.

• Ä˜ú¥òå áåíçèíà äàëå… îò èñê˜è, îòê˜èòè ïëàìúöè, ñèãíàëíè ëàìïè, òîïëèíà

è ä˜óãè çàïàëèòåëíè èçòî…íèöè.

• ﬁ˜îâå˜âàéòå …åñòî ãî˜èâîï˜îâîäèòå, ˜åçå˜âîà˜à, êàïà…êàòà è

ñúåäèíåíèòà çà ïóêíàòèíè è òå…îâå. Çàìåíéòå ãè àêî å íåîáõîäèìî.

• æêî ãî˜èâîòî ñ å ˜àçëåå, èç…àêàéòå äîêàòî òî ñå èçïà˜è, ï˜åäè äà ñòà˜òè˜àòå

äâèãàòåë.

1. ﬁî…èñòåòå çàìú˜ñâàíåòî è íàñëîâàíèòà îêîëî êàïà…êàòà íà ˜åçå˜âîà˜à çà

ãî˜èâî. Ñâàëåòå êàïà…êàòà (A)(·èãó˜à3).

2. ‹àïúëíåòå ˜åçå˜âîà˜à çà ãî˜èâî (B) ñ áåíçèí. Çà äà ïîçâîëèòå ˜àçμè˜åíèå íà

áåíçèíà, íå ïúëíåòå íàä äîëíàòà îñíîâà íà ãú˜ëîâèíàòà çà íàëèâàíå íà

ãî˜èâî (C).

3. ﬁîñòàâåòå îá˜àòíî êàïà…êàòà.

Êàê äà ñòàðòèðàòå äâèãàòåëÿ - Ôèãóðà

Áúðçîòî îòòåãëÿíå íà ïóñêîâîòî âúæå (îáðàòåí óäàð) ùå ïðèäúðïà

èçöÿëî ðúêàòà âè êúì äâèãàòåëÿ ïî-áúðçî, îòêîëêîòî âèå ìîæåòå äà

ÿ îòäðúïíåòå.

Òîâà ìîæå äà ïðè÷èíè ñ÷óïåíè êîñòè, ôðàêòóðè, êîíòóçèè è

íàâÿõâàíèÿ.

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

• ÿîãàòî ñòà˜òè˜àòå äâèãàòåë, èçòåãëåòå áàâíî âú¥åòî íà ñòà˜òå˜à, äîêàòî

óñåòèòå ñúï˜îòèâëåíèå, à ïîñëå ˜çêî ä˜úïíåòå, çà äà èçáåãíåòå îá˜àòíè

óäà˜.

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

Áåíçèíúò è íåãîâèòå ïàðè ñà èçêëþ÷èòåëíî îãíåîïàñíè è

èçáóõëèâè.

Ïîæàð èëè âçðèâ ìîãàò äà ïðè÷èíÿò ñåðèîçíè îáãàðÿíèÿ èëè ñìúðò.

Ïðè ñòàðòèðàíå íà äâèãàòåëÿ

• ‡âå˜åòå ñå, …å çàïàëèòåëíàòà ñâåù, μóìîçàãëóμèòåë, êàïà…êàòà íà

˜åçå˜âîà˜à çà ãî˜èâî è âúçäóμíè ôèëòú˜ ñà íà ìñòîòî ñè è ñà îáåçîïàñåíè.

• ‹å ˜àçâú˜òàéòå äâèãàòåë ñ èçâàäåíà çàïàëèòåëíà ñâåù.

• æêî äâèãàòåëò ñå çàäàâè, ïîñòàâåòå ñìóêà…à (àêî èìà òàêúâ) íà ïîçèöè

∆open/run∆, ï˜åìåñòåòå ˜ú…íàòà ãàç (àêî èìà òàêàâà) íà ïîçèöè∆fast∆ è

˜àçâú˜òàéòå, äîêàòî äâèãàòåëò ñòà˜òè˜à.

14 BRIGGSandSTRATTON.COM

Äâèãàòåëèòå èçïóñêàò âúãëåðîäåí îêèñ, êîéòî å îòðîâåí ãàç, áåç

ìèðèñ è öâÿò.

Âäèøâàíåòî íà âúãëåðîäåí îêèñ ìîæå äà ïðè÷èíè ãàäåíå,

ïðèïàäúê èëè ñìúðò.

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

• Ñòà˜òè˜àéòå è ˜àáîòåòå ñ äâèãàòåë íàâúí.

• ‹å ñòà˜òè˜àéòå è íå ˜àáîòåòå ñ äâèãàòåë â çàòâî˜åíî ïîìåùåíèå, äî˜è è ï˜è

îòâî˜åíè â˜àòè èëè ï˜îçî˜öè.

ÂÍÈÌÀÍÈÅ: ‹àñòîùèò äâèãàòåë ñå äîñòàâ îò Briggs & Stratton áåç ìàñëî.

ﬁ˜åäè äà ñòà˜òè˜àòå äâèãàòåë ñå óâå˜åòå, …å ñòå íàëåëè ìàñëî â íåãî ñïî˜åä

èíñò˜óêöèèòå â òîâà ˜úêîâîäñòâî. æêî ãî ñòà˜òè˜àòå áåç ìàñëî, òîé ùà ñå

ïîâ˜åäè áåç äà áúäå âúçìî¥íî äà ñå ˜åìîíòè˜à è ãà˜àíöèòà íìà äà ïîê˜èâà

ùåòàòà.

1. ﬁ˜îâå˜åòå íèâîòî íà ìàñëîòî. ‹àï˜àâåòå ñï˜àâêà â ˜àçäåëà Êàê ñå

ïðîâåðÿâà/íàëèâà ìàñëî .

2. ‡âå˜åòå ñå, …å óï˜àâëåíèòà íà ñúî˜ú¥åíèåòî, àêî èìà òàêèâà, ñà èçêë˚…åíè.

‹àï˜àâåòå ñï˜àâêà â ˜úêîâîäñòâîòî çà ˜àáîòà îòíîñíî ìåñòàòà è ˜àáîòàòà ñ

òåçè óï˜àâëåíè.

3. ﬁ˜åìåñòåòå ëîñòà íà ñìóêà…à (A) íà ä˜îñåëè˜àùà

ïîçèöè (·èãó˜à 4).

Çàáåëåæêà: ›áèêíîâåíî èçïîëçâàíåòî íà ñìóêà… íå å íåîáõîäèìî ï˜è

ïîâòî˜íî ñòà˜òè˜àíå íà òîïúë äâèãàòåë.

4. ﬁ˜åìåñòåòå ëîñòà íà ˜ú…íàòà ãàç (B), àêî èìà òàêàâà, íà áú˜çè îáî˜îòè

ˆàáîòåòå ñ äâèãàòåë ï˜è ˜ú…íà ãàç íà áú˜çè îáî˜îòè.

5. ﬁ˜è äâèãàòåëè, ñíàáäåíè ñúñ ñòîï êë˚…(C), ïîñòàâåòå êë˚…à íà ïîçèöè on

(âêë.).

6. Çä˜àâî ä˜ú¥òå ˜úêîõâàòêàòà íà âú¥åòî íà ñòà˜òå˜à (D). ¤çòåãëåòå áàâíî

˜úêîõâàòêàòà íà âú¥åòî íà ñòà˜òå˜à, äîêàòî ïî…óâñòâàòå ñúï˜îòèâëåíèå,

ñëåä êîåòî ãî ä˜úïíåòå ˜çêî.

Çàáåëåæêà: æêî äâèãàòåëò íå ñòà˜òè˜à ñëåä ò˜è îïèòà, èäåòå íà àä˜åñ

BRIGGSandSTRATTON.COM èëè ñå îáàäåòå íà òåëåôîí 1-800-233-3723 (â

ÑæÂ).

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ: Ÿú˜çîòî îòòåãëíå íà âú¥åòî íà ñòà˜òå˜à

(îá˜àòåí óäà˜) ùå ï˜èòåãëè öëàòà âè ˜úêà êúì äâèãàòåë ïî-áú˜çî,

îòêîëêîòî âèå ìî¥åòå äà  îòòåãëèòå. ‚îâà áè ìîãëî äà äîâåäå äî ñ…óïåíè

êîñòè, ô˜àêòó˜è, íàâõâàíè è êîíòóçèè. ﬁ˜è ñòà˜òè˜àíå íà äâèãàòåë

èçòåãëåòå áàâíî âú¥åòî íà ñòà˜òå˜à, äîêàòî ïî…óâñòâàòå ñúï˜îòèâëåíèå,

ñëåä êîåòî ãî ä˜úïíåòå ˜çêî, çà äà èçáåãíåòå îá˜àòíè óäà˜.

7. Âîì äâèãàòåëò çàã˜åå, ïîñòàâåòå ëîñòà íà ñìóêà…à (A)íà

˜àáîòíà

ïîçèöè.

Êàê äà ñïðåòå äâèãàòåëÿ - Ôèãóðà

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

Áåíçèíúò è íåãîâèòå ïàðè ñà èçêëþ÷èòåëíî îãíåîïàñíè è

èçáóõëèâè.

Ïîæàð èëè âçðèâ ìîãàò äà ïðè÷èíÿò ñåðèîçíè îáãàðÿíèÿ èëè ñìúðò.

• ‹å çàïóμâàéòå êàìå˜àòà íà êà˜áó˜àòî˜à, çà äà ñï˜åòå äâèãàòåë.

ﬁ˜è ìîäåëèòå ñ ëîñò çà ˜ú…íà ãàç (B), ï˜åìåñòåòå ëîñòà íà áàâíà

è ïîñëå íà

ñòîï

ïîçèöè (âè¥òå ·èãó˜à 4).

èëè

ﬁ˜åìåñòåòå ñòîï êë˚…à (C) íà ïîçèöè ñòîï.

Òåõíè÷åñêî îáñëóæâàíå

Èçïîëçâàéòå åäèíñòâåíî îðèãèíàëíè ìàøèííè ðåçåðâíè ÷àñòè. ×àñòè ñ äðóã

ïðîèçõîä ìîæå äà íå ïàñâàò äîáðå, ìîæå äà ïîâðåäÿò óñòðîéñòâîòî è ìîãàò

äà äîâåäàò äî íàðàíÿâàíå. ›ñâåí òîâà, èçïîëçâàíåòî íà …àñòè ñ ä˜óã ï˜îèçõîä

ìî¥å äà àíóëè˜à âàμàòà ãà˜àíöè.

‹èå âè ï˜åïî˜ú…âàìå äà ïîñåòèòå ›òî˜èçè˜àí ñå˜âèçåí ï˜åäñòàâèòåë íà Briggs &

Stratton çà âñè…êè îïå˜àöèè ïî òåõíè…åñêîòî è ñå˜âèçíîòî îáñëó¥âàíå íà

äâèãàòåë è ˜åçå˜âíèòå …àñòè.

ÂÍÈÌÀÍÈÅ: ◊ñè…êè êîìïîíåíòè, èçïîëçâàíè ï˜è ï˜îèçâîäñòâîòî íà òîçè

äâèãàòåë, ò˜áâà äà áúäàò íà ìñòîòî ñè çà ï˜àâèëíàòà ìó ˜àáîòà.

Êîíòðîë íà åìèñèèòå

Ïîääðúæêàòà, ñìÿíàòà èëè ðåìîíòúò íà óñòðîéñòâàòà çà êîíòðîë íà

âðåäíèòå åìèñèè ìîãàò äà áúäàò èçâúðøâàíè îò âñåêè ðåìîíòåí öåõ èëè

òåõíèê, ðåìîíòèðàùè äâèãàòåëè, êîèòî íå ñå èçïîëçâàò çà òðàíñïîðòíè öåëè.

◊ñå ïàê, çà äà ïîëó…èòå ∆áåçïëàòíî∆ îáñëó¥âàíå íà óñò˜îéñòâàòà çà êîíò˜îë íà

â˜åäíèòå åìèñèè, ˜àáîòàòà ò˜áâà äà áúäå èçâú˜μåíà îò óïúëíîìîùåí çàâîäñêè

ï˜åäñòàâèòåë. ‹àï˜àâåòå ñï˜àâêà â øà˜àíöèòà îòíîñíî â˜åäíèòå ìèñëè.

Ñëó÷àéíî èñêðåíå ìîæå äà äîâåäå äî ïîæàð èëè ïîðàçÿâàíå îò

åëåêòðè÷åñêè òîê.

Íåâîëíî ñòàðòèðàíå ìîæå äà äîâåäå äî çàõâàùàíå, òðàâìàòè÷íà

àìïóòàöèÿ èëè äî ðàíÿâàíå.

Îïàñíîñò îò ïîæàð

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

Ïðåäè èçâúðøâàíå íà ðåãóëèðîâêè è ïîïðàâêè:

• ›òêà…åòå êàáåëà íà çàïàëèòåëíàòà ñâåù è ãî ä˜ú¥òå äàëå… îò íå.

• ¤çïîëçâàéòå ñàìî ïîäõîäùè èíñò˜óìåíòè.

• ‹å çàñòîïî˜âàéòå ñ ˜åãóëè˜àùàòà ï˜ó¥èíà, ëîñòîâèòå ñèñòåìè èëè ñ ä˜óãè

…àñòè, çà äà ïîâèμèòå îáî˜îòèòå íà äâèãàòåë.

• Replacement parts must be the same and installed in the same position as the

original parts.

• ‹å óä˜éòå ìàõîâèêà ñ …óê èëè òâú˜ä ï˜åäìåò, çàùîòî òîé ìî¥å äà ñå ñò˜îμè

ïî â˜åìå íà ˜àáîòà.

Ïðè èçïðîáâàíå çà èñêðà:

• ¤çïîëçâàéòå îäîá˜åí òèï òåñòå˜ çà ñâåùè.

• ‹å ï˜àâåòå ï˜îâå˜êà çà èñê˜à ï˜è èçâàäåíà çàïàëèòåëíà ñâåù.

Ãðàôèê çà òåõíè÷åñêî îáñëóæâàíå

Ñëåä ïúðâèòå 5 ÷àñà

• Äà ñå ñìåí ìàñëîòîl

Íà âñåêè 8 ÷àñà èëè åæåäíåâíî

• ﬁ˜îâå˜åòå íèâîòî íà ìàñëîòî â äâèãàòåë

• ﬁî…èñòâàéòå ï˜îñò˜àíñòâîòî îêîëî μóìîçàãëóμèòåë è óï˜àâëåíèòà

• ﬁî…èñòåòå çàùèòíè êàïàê çà ï˜úñòèòå

Íà âñåêè 25 ÷àñà èëè åæåãîäíî

• ﬁî…èñòåòå âúçäóμíè ôèëòú˜ *

• ﬁî…èñòåòå ï˜åäôèëòú˜à *.

Íà âñåêè 50 ÷àñà èëè åæåãîäíî

• Ñìåíåòå ìàñëîòî â äâèãàòåë

• Äà ñå ï˜åãëå¥äàò μóìîçàãëóμèòåë è èñê˜îãàñèòåë

Íà âñåêè 100 ÷àñà

• Ñìåíåòå ìàñëîòî â çúáíè ˜åäóêòî˜ (àêî èìà òàêúâ)

Åæåãîäíî

• Äà ñå ñìåí âúçäóμíè ôèëòú˜

• Äà ñå ñìåí ï˜åäôèëòú˜à

• Äà ñå ñìåí çàïàëèòåëíàòà ñâåù

• ﬁî…èñòâàéòå âúçäóμíàòà îõëàäèòåëíà ñèñòåìà *

* Äà ñå ïî…èñòâà ïî-…åñòî ï˜è çàï˜àμåíà ñ˜åäà, èëè êîãàòî âúâ âúçäóõà ñå

íîñò …àñòèöè.

Ðåãóëèðàíå íà êàðáóðàòîðà

‹èêîãà íå ï˜àâåòå íàñò˜îéêè íà êà˜áó˜àòî˜à. ÿà˜áó˜àòî˜úò å ˜åãóëè˜àí â

çàâîäà, çà äà ˜àáîòè åôåêòèâíî ï˜è ïîâå…åòî óñëîâè. ◊ñå ïàê, àêî ñå íàëàãàò

íàñò˜îéêè, çà ñå˜âèçíî îáñëó¥âàíå ñå îáú˜íåòå êúì íêîé ‡ïúëíîìîùåí

ï˜åäñòàâèòåë íà Briggs & Stratton.

ÂÍÈÌÀÍÈÅ: ﬁ˜îèçâîäèòåëò íà îáî˜óäâàíåòî, íà êîåòî òîçè äâèãàòåë ùå áúäå

ìîíòè˜àí, îï˜åäåë ìàêñèìàëíèòå îáî˜îòè, ï˜è êîèòî ùå ˜àáîòè. Íå

íàäâèøàâàéòå òåçè îáî˜îòè.

Êàê ñå ñìåíÿ çàïàëèòåëíàòà ñâåù - Ôèãóðà

ﬁ˜îâå˜âàéòå ìå¥äèíàòà (A,·èãó˜à5)ñòåëåíêàëèáú˜(B).æêîñåíàëàãà,

˜åãóëè˜àéòå ìå¥äèíàòà. ﬁîñòàâåòå è çàòåãíåòå çàïàëèòåëíàòà ñâåù ñ

ï˜åïî˜ú…âàíè âú˜òù ìîìåíò. ›òíîñíî ˜åãóëè˜àíåòî íà ìå¥äèíàòà èëè

âú˜òùè ìîìåíò íàï˜àâåòå ñï˜àâêà â ˜àçäåë Òåõíè÷åñêè äàííè.

Çàáåëåæêà: ‹à íêîè ìåñòà, ìåñòíèò çàêîí èçèñêâà óïîò˜åáàòà íà ˜åçèñòî˜íà

ñâåù, çà äà ñå ïîòèñêàò ˜àäèî ñìóùåíèòà. æêî òîçè äâèãàòåë å ôàá˜è…íî

îáî˜óäâàí ñ ˜åçèñòî˜íà ñâåù, èçïîëçâàéòå ñúùè òèïñâåùçàñìíà è.

Äà ñå ïðîâåðÿâà âíèìàòåëíî øóìîçàãëóøèòåëÿ è

èñêðîãàñèòåëÿ - Ôèãóðà

Ðàáîòåùèòå äâèãàòåëè îòäåëÿò òîïëèíà. ×àñòèòå íà äâèãàòåëèòå,

îñîáåíî øóìîçàãëóøèòåëÿ, ñòàâàò èçêëþ÷èòåëíî ãîðåùè.

Ïðè äîïèð ìîæå äà ïîëó÷èòå ñåðèîçíî èçãàðÿíå.

Ãîðèìèòå îòïàäúöè, êàòî ëèñòà, òðåâè, õðàñòàëàê è äðóãè, ìîãàò äà

ñå çàïàëÿò.

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

• ›ñòàâåòå μóìîçàãëóμèòåë, öèëèíäú˜à íà äâèãàòåë è ˜åá˜àòà äà ñå

îõëàäò, ï˜åäè äà ãè äîêîñâàòå.

• ›òñò˜àíåòå íàò˜óïàíèòå îòëîìêè îêîëî μóìîçàãëóμèòåë è öèëèíäú˜à.

• ﬂîíòè˜àéòå è ïîääú˜¥àéòå â ˜àáîòíî ñúñò îíèå èñê˜îãàñèòåë, ï˜åäè äà

èçïîëçâàòå äâèãàòåë íà çàëåñåíè ìåñòà, ç àò˜åâåíè ïëîùè, ïëîùè ñ õ˜àñòè è

íåîá˜àáîòåíè ìåñòà. Âàòúò ÿàëèôî˜íè èçèñêâà òîâà (â ˆàçäåë 4442 íà

ÿàëèôî˜íèéñêè ï˜àâèëíèê çà îáùåñòâåíè ˜åñó˜ñè). ◊úçìî¥íîåä˜óãèùàòè

äà èìàò ïîäîáíè çàêîíè. ·åäå˜àëíèòå çàêîíè ñå ï˜èëàãàò íà ôåäå˜àëíà

òå˜èòî˜è.

ﬁ˜îâå˜åòå μóìîçàãëóμèòåë (A,·èãó˜à6) çà ïóêíàòèíè, êî˜îçè èëè ä˜óãà

ïîâ˜åäà. Ñâàëåòå èñê˜îãàñèòåë (B) è ãî ï˜îâå˜åòå çà ïîâ˜åäà èëè çàïóμâàíå

ñúñ ñà¥äè. æêî ñå íàëàãàò ˜åçå˜âíè …àñòè, óâå˜åòå ñå, …å ùå ïîëçâàòå ñ àìî

î˜èãèíàëíè òàêèâà çà îáî˜óäâàíåòî.

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ: ˆåçå˜âíèòå …àñòè ò˜áâà äà áúäàò ñúñ ñúùîòî

êà…åñòâî è äà ñ å ìîíòè˜àò â ñúùîòî ïîëî¥åíèå êàêòî î˜èãèíàëíèòå, çàùîòî â

ï˜îòèâåí ñëó…àé ìî¥å äà ñå âúçíèêíå ïî¥à˜.

Êàê äà ñå ñìåíÿ ìàñëîòî - Ôèãóðà

7 8

ÂÍÈÌÀÍÈÅ: ›ò˜àáîòèëîòî ìàñëî å îïàñåí îòïàäú…åí ï˜îäóêò è ò˜áâà äà ñå

ñêëàäè˜à ïî ïîäõîäù íà…èí. ‹å ãî èçõâú˜ëéòå ñ äîìàêèíñêèòå îòïàäúöè.

ﬁ˜îâå˜åòå ñúâìåñòíî ñ îáùèíñêèòå âëàñòè, çà îáñëó¥âàù öåíòú˜ èëè çà

ï˜åäñòàâèòåë íà èíñòàëàöèè çà áåçîïàñíî äåïîíè˜àíå/˜åöèêëè˜àíå íà

îò˜àáîòèëîòî ìàñëî.

Èçòî÷åòå î òðàáîòèëîòî ìàñëî

1. ﬁ˜è èçêë˚…åí, íî âñå îùå òîïúë äâèãàòåë, îòêà…åòå êàáåëà íà çàïàëèòåëíàòà

ñâåù (A) è ãî ä˜ú¥òå íà ˜àçñòîíèå îò ñâåùòà (·èãó˜à 7).

2. Ñâàëåòå ï˜îáêàòà çà èçòî…âàíå íà ìàñëîòî (B, ·èãó˜à 8). ¤çòî…åòå ìàñëîòî â

ïîäõîäù çà öåëòà ñúä.

Çàáåëåæêà: ◊ñêà îò ïîêàçàíèòå ï˜îáêè çà èçòî…âàíå íà ìàñëîòî (C)ìî¥åäà

áúäå ìîíòè˜àíà íà äâèãàòåë.

3. Ñëåä êàòî ìàñëîòî å èçòî…åíî, ïîñòàâåòå è çàòåãíåòå ï˜îáêàòà.

Íàëèâàíå íà ìàñëî

• ˆàçïîëî¥åòå õî˜èçîíòàëíî äâèãàòåë.

• ﬁî…èñòåòå ìñòîòî îêîëî îòâî˜à çà íàëèâàíå íà ìàñëî îò âñè…êè îòëîìêè.

• ‹àï˜àâåòå ñï˜àâêà â ˜àçäåë Òåõíè÷åñêè äàííè îòíîñíî âìåñòèìîñòòà çà

ìàñëîòî.

1. Ñâàëåòå êàïà…êàòà íà îòâî˜à çà íàëèâàíå íà ìàñëî (D, ·èãó˜à 8).

2. ‹àëåéòå âíèìàòåëíî ìàñëî â äâèãàòåë ï˜åç îòâî˜à çà íàëèâàíå (E).

‹àïúëíåòå äî òî…êàòà íà ï˜åëèâàíå.

3. ﬁîñòàâåòå íà ìñòîòî è çàòåãíåòå êàïà…êàòà íà îòâî˜à çà ïúëíåíå ñ ìàñëî.

Êàê äà ñå îáñëóæâà âúçäóøíèÿ ôèëòúð - Ôèãóðà

9 10

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

Áåíçèíúò è íåãîâèòå ïàðè ñà èçêëþ÷èòåëíî îãíåîïàñíè è

èçáóõëèâè.

Ïîæàð èëè âçðèâ ìîãàò äà ïðè÷èíÿò ñåðèîçíè îáãàðÿíèÿ èëè ñìúðò.

• ‹èêîãà íå ñòà˜òè˜àéòå è íå ˜àáîòåòå ñ äâèãàòåë ï˜è ñâàëåí ôèëòú˜åí

êîìïëåêò èëè âúçäóμåí ôèëòú˜.

ÂÍÈÌÀÍÈÅ: ‹å èçïîëçâàéòå ñãúñòåí âúçäóõ èëè ˜àçòâî˜èòåëè, çà äà ïî…èñòâàòå

ôèëòú˜à. Ñãúñòåíèò âúçäóõ ìî¥å äà ïîâ˜åäè ôèëòú˜à, à ˜àçòâî˜èòåëèòå ãî

˜àçòâà˜ò.

Ñèñòåìàòà íà âúçäóμíè ôèëòú˜ èçïîëçâà ôèëòú˜ îò íàãúíàò ôèëòú˜åí

ìàòå˜èàë ñ ï˜åäôèëòú˜ ïî îïöè. ﬁ˜åäôèëòú˜úò ìî¥å äà áúäå ï˜îìèâàí è

ïîëçâàí ïîâòî˜íî.

1. ‹àòèñíåòå íàâúò˜å áëîêè˜àùèòå çúá…åòà (A) è èçòåãëåòå íàâúí êàïàêà (B).

◊è¥òå â ·èãó˜à 9.

2. Ñâàëåòå ôèëòú˜à (D). ◊è¥òå â ·èãó˜à 10.

3. Çà äà ïî…èñòèòå íàñëîâàíèòà, ëåêî ïî…óêâàéòå ôèëòú˜à âú˜õó òâú˜äà

ïîâú˜õíîñò. æêî ôèëòú˜úò å ï˜åêîìå˜íî çàìú˜ñåí, çàìåíåòå ãî ñ íîâ.

4. ‹àòèñíåòå ê˜à íà ôèëòú˜à â îñíîâàòà, êàêòî å ïîêàçàíî. ‡âå˜åòå ñå, …å

ôèëòú˜à ïàñâà ñòàáèëíî â îñíîâàòà.

5. ﬂîíòè˜àéòå êàïàêà. ‡âå˜åòå ñå, …å áëîêè˜àùèòå çúá…åòà ñà çàê˜åïåíè.

Êàê äà ñìåíèòå ìàñëîòî â çúáíèÿ ðåäóêòîð - Ôèãóðà

æêî äâèãàòåëò âè å îáî˜óäâàí ñúñ çúáåí ˜åäóêòî˜, äà ñå îáñëó¥âà êàêòî

ñëåäâà.

1. Ñâàëåòå ï˜îáêàòà çà ïúëíåíå íà ìàñëî (B) è ï˜îáêàòà çà èçìå˜âàíå íà íèâîòî

ìó (C).

2. Ñâàëåòå ï˜îáêàòà çà èçòî…âàíå íà ìàñëîòî (A, ·èãó˜à 11) è èçòî…åòå ìàñëîòî

â ïîäõîäùñúä.

3. ﬁîñòàâåòå è çàòåãíåòå ï˜îáêàòà çà ìàñëîòî.

4. Ñâàëåòå ï˜îáêàòà çà ïúëíåíå íà ìàñëî (B) è ï˜îáêàòà çà èçìå˜âàíå íà íèâîòî

ìó (C).

5. Çà äà íàïúëíèòå îòíîâî âíèìàòåëíî íàëåéòå ˜åäóêòî˜íîòî ìàñëî â îòâî˜à çà

íàëèâàíå (‹àï˜àâåòå ñï˜àâêà â ˜àçäåë Òåõíè÷åñêè äàííè). ﬁ˜îäúë¥àâàéòå

äà íàëèâàòå, äîêàòî ìàñëîòî ï˜îòå…å îò îòâî˜à çà ìå˜åíå íà íèâîòî (C).

6. ﬁîñòàâåòå è çàòåãíåòå ï˜îáêàòà íà îòâî˜à çà ìå˜åíå íà íèâîòî ìàñëîòî.

7. ﬁîñòàâåòå è çàòåãíåòå ï˜îáêàòà íà îòâî˜à çà ïúëíåíå ñ ìàñëî.

Âàæíî: ﬁ˜îáêàòà íà îòâî˜à çà ïúëíåíå ñ ìàñëî èìà âåíòèëàöèîíåí îòâî˜ (D)

èò˜áâà äà áúäå ìîíòè˜àíà íà âú˜õà íà êàïàêà íà ï˜åäàâàòåëíàòà êóòè,

êàêòî å ïîêàçàíî.

Êàêäàñåïî÷èñòâàâúçäóøíî-îõëàäèòåëíàòà

ñèñòåìà - Ôèãóðà

Ðàáîòåùèòå äâèãàòåëè îòäåëÿò òîïëèíà. ×àñòèòå íà äâèãàòåëèòå,

îñîáåíî øóìîçàãëóøèòåëÿ, ñòàâàò èçêëþ÷èòåëíî ãîðåùè.

Ïðè äîïèð ìîæå äà ïîëó÷èòå ñåðèîçíî èçãàðÿíå.

Ãîðèìèòå îòïàäúöè, êàòî ëèñòà, òðåâè, õðàñòàëàê è äðóãè, ìîãàò äà

ñå çàïàëÿò.

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

• ›ñòàâåòå μóìîçàãëóμèòåë, öèëèíäú˜à íà äâèãàòåë è ˜åá˜àòà äà ñå

îõëàäò, ï˜åäè äà ãè äîêîñâàòå.

• ›òñò˜àíåòå íàò˜óïàíèòå îòëîìêè îêîëî μóìîçàãëóμèòåë è öèëèíäú˜à.

ÂÍÈÌÀÍÈÅ: ‹å èçïîëçâàéòå âîäà, çà äà ïî…èñòâàòå äâèãàòåë. ◊îäàòà ìî¥å äà

çàìú˜ñè ãî˜èâíàòà ñèñòåìà. ¤çïîëçâàéòå …åòêà èëè ñóõ ïëàò, çà äà ãî ïî…èñòèòå.

‹àñòîùèò äâèãàòåë å ñ âúçäóμíî îõëà¥äàíå. Çàìú˜ñâàíåòî è íàñëîâàíèòà

ìîãàò äà îã˜àíè…àò âúçäóμíè ïîòîê è äà ï˜è…èíòï˜åã˜âàíå íà äâèãàòåë,

âîäåùî äî ñëàáè ïîêàçàòåëè è íàìàëâàíå íà åêñïëîàòàöèîííè ìó ñ˜îê.

ﬁ˜îâå˜âàéòå äâèãàòåë çà íàò˜óïàíî çàìú˜ñâàíå èëè íàñëîâàíè, êîèòî

ìîãàò äà îã˜àíè…àò âúçäóμíè ïîòîê. ¤çïîëçâàéòå …åòêà èëè ñóõ ïëàò, çà äà

îòñò˜àíèòå íàñëî âàíèòà îò ï˜åäïàçèòåë íà ï˜úñòèòå (A)(·èãó˜à12). ﬁàçåòå

…èñòè ëîñòîâàòà ñèñòåìà, ï˜ó¥èíèòå è óï˜àâëåíèòà (B). ﬁàçåòå ï˜îñò˜àíñòâîòî

îêîëî è çàä μóìîçàãëóμ

èòåë (C) ñâîáîäíî îò âñêàêâè ãî˜èìè íàñëîâàíè.

Ñêëàäèðàíå

Áåíçèíúò è íåãîâèòå ïàðè ñà èçêëþ÷èòåëíî îãíåîïàñíè è

èçáóõëèâè.

Ïîæàð èëè âçðèâ ìîãàò äà ïðè÷èíÿò ñåðèîçíè îáãàðÿíèÿ èëè

ñìúðò.

ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ

Êîãàòî ñêëàäèðàòå áåíçèí èëè îáîðóäâàíå ñ ãîðèâî â ðåçåðâîàðà

• Ñêëàäè˜àéòå äàëå… îò ïåùè, ïå…êè, âîäîíàã˜åâàòåëè èëè ä˜óãè åëåêò˜è…åñêè

ï˜èáî˜è, êîèòî èìàò ñèãíàëíè ëàìïè èëè ä˜óãè çàïàëèòåëíè èçòî…íèöè,

çàùîòî òå ìîãàò äà âúçïëàìåíò áåíçèíîâèòå ïà˜è.

Ãîðèâíà ñèñòåìà

øî˜èâîòî îñòà˜âà ñëåä ñêëàäè˜àíå çà ïîâå…å îò 30 äíè. ›ñòà˜ëîòî ãî˜èâî âîäè

äî îá˜àçóâàíå íà êèñåëèííè è ñìîëåñòè îòëî¥åíè â ãî˜èâíàòà ñèñòåìà èëè ïî

îñíîâíèòå …àñòè íà êà˜áó˜àòî˜à. Çà äà çàïàçèòå ãî˜èâîòî ñâå¥î, èçïîëçâàéòå

ñòàáèëèçàòî˜à çà ãî˜èâî FRESH START

íà Briggs & Stratton, êîéòî å äîñòúïåí

ïîä ôî˜ìàòà òå…íà äîáàâêà èëè ôëàêîí çà êàïêîâî ïîäàâàíå.

æêî ñå äîáàâ ñòàáèëèçàòî˜à çà ãî˜èâîòî ñúãëàñíî èíñò˜óêöèèòå, íìà íó¥äà

áåíçèíúò äà ñå èçòî…âà. ›ñòàâåòå äâèãàòåëò äà ˜àáîòè îêîëî 2 ìèíóòè, çà äà

öè˜êóëè˜à ñòàáèëèçàòî˜úò â ãî˜èâíàòà ñèñòåìà. ‚îãàâà äâèãàòåëò è ãî˜èâîòî

ìîãàòäàñåñúõ˜àíâàò äî 24 ìåñåöà.

æêî áåíçèíúò â äâèãàòåë íå å áèë îá˜àáîòâàí ñúñ ñòàáèëèçàòî˜, òîé ò˜áâà äà

áúäå èçòî…åí â ïîäõîäù çà öåëòà ñúä. ›ñòàâåòå äâèãàòåëò äà ˜àáîòè, äîêàòî

ñï˜å ïî˜àäè èç…å˜ïâàíå íà ãî˜èâîòî. Çà äà ïîääú˜¥àòå ñâå¥åñòòà íà ãî˜èâîòî

ï˜è ñêëàäè˜àíåòî ìó, ï˜åïî˜ú…âàìå èçïîëçâàíåòî íà ñòàáèëèçàòî˜.

Ìàñëîòî íà äâèãàòåëÿ

Äîêàòî äâèãàòåëò å âñå îùå òîïúë ñìåíåòå ìàñëîòî.

BRIGGSandSTRATTON.COM

Îòêðèâàíå è îòñòðàíÿâàíå íà íåèçïðàâíîñòè

‹ó¥äàåòå ëè ñå îò ïîìîù? ﬁîñåòåòå BRIGGSandSTRATTON.COM èëè ñå îáàäåòå

íà 1-800-233-3723..

íè÷åñêè äàííè

Ñïåöèôèêàöèè çà äâèãàòåëÿ

ﬂîäåë 90000

ˆàáîòåí îáåì 9,02 èí…à

(148 cm

)

◊úò˜åμåí äèàìåòú˜ íà öèëèíäú˜à 2,562 èí…à (65,08 mm)

ˆàáîòåí õîä íà áóòàëîòî 1,750 èí…à (44,45 mm)

◊ìåñòèìîñò çà ìàñëî 18 -- 20 óíöèè (0,54 -- 0,59 L)

ﬂàñëî çà çúáíè ˜åäóêòî˜ 80W-90

Ðåãóëèðîâú÷íè äàííè *

ﬂîäåë 90000

¤ñê˜îâà ìå¥äèíà íà çàïàëèòåëíàòà ñâåù 0,030 èí…à (0,76 mm)

◊ú˜òù ìîìåíò çà çàòãàíå íà

çàïàëèòåëíàòà ñâåù

180 ëèá˜è.èí…à (20 Nm)

◊úçäóμíà ìå¥äèíà ìå¥äó ˜îòî˜à è

ñòàòî˜à

0,006 - 0,010 èí…à (0,15 - 0,25 mm)

ﬂå¥äèíà íà ñìóêàòåëíè êëàïàí 0,005 - 0,007 èí…à (0,13 - 0,18 mm)

ﬂå¥äèíà íà èçïóñêàòåëíè êëàïàí 0,007 - 0,009 èí…à (0,18 - 0,23 mm)

* ﬂîùíîñòòà íà äâèãàòåë íàìàëâà ñ 3,5% íà âñåêè 1000 ôóòà (300 ìåò˜à) íàä

ìî˜ñêîòî íèâî è ñ 1% çà âñåêè 10° F(5,6° C) íàä 77° F(25° C). Äâèãàòåëòùå

˜àáîòè çàäîâîëèòåëíî ï˜è íàêëîí äî 15°. ‹àï˜àâåòå ñï˜àâêà â ˆúêîâîäñòâîòî çà

˜àáîòà ñ îáî˜óäâàíåòî çà áåçîïàñíèòå ã˜àíèöè çà ˜àáîòà íà íàêëîíè.

Îáèêíîâåíè ÷àñòè çà ïîääðúæêà n

Ñåðâèçíà ÷àñò Íîìåð íà ÷àñòòà

›âàëåí âúçäóμåí ôèëòú˜ 790166

øî˜èâíà äîáàâêà 5041, 5058

ˆåçèñòî˜íà çàïàëèòåëíà ñâåù 802592

Äúëãîò˜àéíà ïëàòèíåíà çàïàëèòåëíà ñâåù 5062

ÿë˚… çà ñâåù 89838, 5023

¤ñê˜îâ òåñòå˜ 19368

n ‹èå âè ï˜åïî˜ú…âàìå äà ïîñåòèòå íêîé îò ‡ïúëíîìîùåíèòå ï˜åäñòàâèòåëè

íà Briggs & Stratton çà âñè…êè îïå˜àöèè ïî òåõíè…åñêîòî è ñå˜âèçíîòî îáñëó¥âàíå

íà äâèãàòåë è ˜åçå˜âíèòå …àñòè. ¤çïîëçâàéòå ñàìî î˜èãèíàëíè …àñòè íà Briggs &

Stratton.

ÃÀÐÀÍÖÈÎÍÍÀ ÏÎËÈÖÀ ÍÀ ÑÎÁÑÒÂÅÍÈÊÀ ÍÀ ÄÂÈÃÀÒÅË BRIGGS & STRATTON

Màé 2008 ã.

ÿî˜ïî˜àöè Briggs & Stratton ùå ˜åìîíòè˜à èëè ç àìåíè áåçïëàòíî âñêà …àñò (âñè…êè …àñòè) íà äâèãàòåë, êîèòî ñà ïîâ˜åäåíè, ïî˜àäè äåôåêòåí ìàòå˜èàë èëè

ï˜îèçâîäñòâî, èëè ïî˜àäè äâåòå. ‚˜àíñïî˜òíèòå ˜àçõîäè íà èçï˜àòåíèòå çà ˜åìîíò èëè ñìíà …àñòè ïî òàçè ãà˜àíöè ñå ïîåìàò îò êóïóâà…à. ‚àçè ãà˜àíöè å

âàëèäíà çà îï˜åäåëåíè ñ˜îê è å ï˜åäìåò íà óñëîâèòà, ôèêñè˜àíè ïî-äîëó. Çà îáñëó¥âàíå ïî ãà˜àíöèòà ñå îáú˜íåòå êúì íàé-áëèçêè ‡ïúëíîìîùåí

ñå˜âèçåí ï˜åäñòàâèòåë, êîéòî ìî¥å äà îòê˜èåòå â íàμè óêàçàòåë íà àä˜åñ BRIGGSandSTRATTON.com, èëè êàòî ñå îáàäèòå íà òåëåôîí

1-800-233-3723, èëè êàòî å ïîñî…åíî â «≠úëòèòå ñò˜àíèöèt».

Íÿìà äðóãà ñïåöèàëíà ãàðàíöèÿ. Ïîäðàçáèðàùèòå ñå ãàðàíöèè, âêëþ÷èòåëíî òåçè çà ãîäíîñòòà çà ïðîäàæáà èëè çà íÿêàêâà ñïåöèàëíà öåë, ñà

îãðàíè÷åíè äî åäíà ãîäèíà îò äàòàòà íà êóïóâàíå èëè äî ñðîêà, ðàçðåøåí ïî çàêîí, à âñè÷êè ñâúðçàíè ãàðàíöèè ñå èçêëþ÷âàò. Îòãîâîðíîñò çà

ñëó÷àéíè èëè ïîñëåäâàùè ùåòè ñå èçêëþ÷âà â ñòåïåí, ðàçðåøåíà ïî çàêîí. ‹êîè ùàòè èëè ñò˜àíè íå ïîçâîëâàò îã˜àíè…åíè çà â˜åìåò˜àåíåòî íà

ïîä˜àçáè˜àùàòà ñå ãà˜àíöè,àíêîè ùàòè èëè ñò˜àíè íå ïîçâîëâàò èçêë˚…âàíåòî èëè îã˜àíè…àâàíåòî íà ñëó…àéíè èëè ïîñëåäâàùè ùåòè, òàêà …å å

âúçìî¥íî ãî˜íîòî îã˜àíè…åíèå è èçêë˚…åíèå äà íå âà¥è çà âàñ. ‚àçè ãà˜àíöè âè äàâà ñïåöèôè…íè çàêîíîâè ï˜àâà, à âèå ìî¥åòå äà èìàòå è ä˜óãè òàêèâà,

êîèòî ñå èçìåíò â åäèí èëè ä˜óã ùàò, èëè â åäíà èëè ä˜óãà ñò˜àíà.

ÎÃÐÀÍÈ×ÅÍÀ ÃÀÐÀÍÖÈß

ÑÒÀÍÄÀÐÒÍÈ ÃÀÐÀÍÖÈÎÍÍÈ ÓÑËÎÂÈß *

Ìàðêà/Âèä ïðîäóêò

Çà ïîëçâàíå çà ñîáñòâåíè íóæäè Çà ïîëçâàíå çà ïðîìèøëåíè íóæäè

Vanguardt 2 ãîäèíè 2 ãîäèíè

Ñå˜èèñóäúë¥åí¥èâîòt , I/C

,IntektI/C

, IntektPro

2 ãîäèíè 1 ãîäèíà

Ñå˜èèçàñíãMAXt ñ …óãóíåíà ˜èçà Dura-Boret 2 ãîäèíè 1 ãîäèíà

◊ñè…êè ä˜óãè äâèãàòåëè íà Briggs & Stratton 2 ãîäèíè 90 äíè

* ‚åçè ñà íàμèòå ñòàíäà˜òíè ãà˜àíöèîííè óñëîâè, íî å âúçìî¥íî ñëó…àéíî äà èìà äîïúëíèòåëíî ãà˜àíöèîííî ïîê˜èòèå, êîåòî íå å áèëî îï˜åäåëåíî êúì

ìîìåíòà íà ïóáëèêóâàíåòî. Çà ñïèñúêà ñ òåêóùèòå ãà˜àíöèîííè óñëîâè çà âàμè äâèãàòåë ïîñåòåòå àä˜åñà íè â ¤íòå˜íåò BRIGGSandSTRATTON.COM èëè

ñå îáú˜íåòå êúì ‡ïúëíîìîùåí ñå˜âèçåí ï˜åäñòàâèòåë íà Briggs & Stratton.

Äâèãàòåëè, ìîíòè˜àíè íà äîìàμåí ãåíå˜àòî˜ çà åëåêò˜îåíå˜ãè ñà ãà˜àíòè˜àíè ñàìî ïî êëàóçàòà ∆Çà ïîò˜åáèòåëñêî ïîëçâàíå∆. ‹àñòîùàòà ãà˜àíöè íå å

âàëèäíà çà äâèãàòåëè, ìîíòè˜àíè íà îáî˜óäâàíå, ïîëçâàíî êàòî ïú˜âè…íà ìîùíîñò, âìåñòî öåíò˜àëíîòî çàõ˜àíâàíå. Äâèãàòåëè, èçïîëçâàíè çà

ñúñòåçàíèÿ, çà òúðãîâñêè öåëè èëè çà îòäàâàíå ïîä íàåì, íå ñà ïîêðèòè îò ãàðàíöèÿòà.

øà˜àíöèîííèò ïå˜èîä çàïî…âà îò äàòàòà íà êóïóâàíå îò ïú˜âè ïîò˜åáèòåë íà ä˜åáíî èëè îò ê˜àéíè ïîò˜åáèòåë çà ï˜îìèμëåíè íó¥äè è ï˜îäúë¥àâà çà ïå˜èîäà,

ïîñî…åí â òàáëèöàòà ãî˜å. ∆Çà ïîëçâàíå çà ñîáñòâåíè íó¥äè∆ îçíà…àâà ëè…íî èçïîëçâàíå â äîìàêèíñòâî îò ïîò˜åáèòåë íà ä˜åáíî. ∆Çà ïîëçâàíå çà ï˜îìèμëåíè íó¥äè∆

îçíà…àâà âñè…êè ä˜óãè óïîò˜åáè, âêë˚…èòåëíî òú˜ãîâñêà óïîò˜åáà, êàêòî è òàêàâà, ôî˜ìè˜àùà äîõîä èëè îòäàâàíå ïîä íàåì. Ñëåä êàòî âåäíú¥ äâèãàòåëò å áèë

ïîëçâàí çà ï˜îìèμëåíè íó¥äè, ïî-íàòàòúê òîé ù å áúäå ñ…èòàí êàòî äâèãàòåë çà ï˜îìèμëåíè íó¥äè çà öåëèòå íà òàçè ãà˜àíöè.

Íå å íåîáõîäèìà ðåãèñòðàöèÿ íà ãàðàíöèÿòà, çà äà ñå ïîëó÷è ãàðàíöèîííî îáñëóæâàíå çà ïðîäóêòèòå Briggs & Strstton. Ïàçåòå çà äîêàçàòåëñòâî êâèòàíöèÿòà

îò ïîêóïêàòà. Àêî íå îñèãóðèòå äîêàçàòåëñòâî çà íà÷àëíàòà äàòà íà êóïóâàíå, ïðè ïîèñêâàíå íà ãàðàíöèîííî îáñëóæâàíå, äàòàòà íà ïðîèçâîäñòâî íî

ïðîäóêòà ùå áúäå èçïîëçâàíà çà îïðåäåëÿíå íà ãàðàíöèîííèÿ ïåðèîä.

Îòíîñíî âàøàòà ãàðàíöèÿ

Briggs & Stratton ï˜èåìàò ñ ãîòîâíîñò ãà˜àíöèîííè ˜åìîíò è ñå èçâèíâàò çà

ï˜è…èíåíîòî âè íåóäîáñòâî. ◊ñåêè ‡ïúëíîìîùåí ñå˜âèçåí ï˜åäñòàâèòåë ìî¥å äà

èçâú˜μâà ãà˜àíöèîííè ˜åìîíòè. ﬁîâå…åòî ãà˜àíöèîííè ˜åìîíòè ñå ï˜îâå¥äàò

˜óòèííî, íî ïîíêîãà å âúçìî¥íî èñêàíèòà çà ãà˜àíöèîííî îáñëó¥âàíå äà íå

áúäàò ñúîòâåòñòâàùè.

æêîêóïóâà…úòíååñúãëàñåíñ˜åμåíèåòî íà Ñå˜âèçíè ï˜åäñòàâèòåë, ùå ñå

íàï˜àâè ï˜îó…âàíå, çà äà ñå óñòàíîâè äàëè ãà˜àíöèòà ñå ï˜èçíàâà. ¤çèñêâàéòå

îò Ñå˜âèçíè ï˜åäñòàâèòåë äà ï˜åäîñòàâè çà ï˜åãëåä âñè…êè äîïúëíèòåëíè

ôàêòè íà ñâî äèñò˜èáóòî˜ èëè íà çàâîäà. æêî äèñò˜èáóòî˜úò èëè çàâîäúò ˜åμè,

…å òîâà èñêàíå å îï˜àâäàíî, êóïóâà…úò ùå áúäå íàïúëíî îáåçùåòåí çà

äåôåêòíèòå …àñòè. Çà äà ñå èçáåãíå íåäî˜àçóìåíèåòî, êîåòî ìî¥å äà âúçíèêíå

ìå¥äó êóïóâà…à è ï˜åäñòàâèòåë, ïî-äîëó ñà èçá˜îåíè íêîè îò ï˜è…èíèòå çà

ïîâ˜åäà â äâèãàòåë, êîèòî ãà˜àíöèòà íå ïîê˜èâà.

Íîðìàëíî èçíîñâàíå: Äâèãàòåëèòå, êàêòî âñè…êè ìåõàíè…íè óñò˜îéñòâà, ñå

íó¥äàò îò ïå˜èîäè…íà çàìíà íà …àñòè è îáñëó¥âàíå, çà äà ˜àáîòò äîá˜å.

øà˜àíöèòà íå ïîê˜èâà ˜åìîíòà, êîãàòî ï˜è íî˜ìàëíî èçíîñâàíå äàäåíà …àñò èëè

äâèãàòåëò ñà èç…å˜ïàëè ¥èâîòà ñè. øà˜àíöèòà íå ñå ï˜èëàãà, àêî â äâèãàòåë ñå

ñëó…è ïîâ˜åäà, ïî˜àäè íåï˜àâèëíî ïîëçâàíå èëè îòñúñòâèå íà ˜óòèííà

ïîää˜ú¥êà, ò˜àíñïî˜òè˜àíå, ìàíèïóëè˜àíå, ñúõ˜àíâàíå èëè íåï˜àâèëåí

ìîíòà¥. Ñúùî òàêà, ãà˜àíöèòà ñå ãóáè, àêî ñå˜èéíèò íîìå˜ íà äâèãàòåë å

îòñò˜àíåí èëè ïî íåãî ñà ï˜àâåíè ï˜îìåíè.

Íåïðàâèëíî ïîääúðæàíå: ≠èâîòúò íà äàäåí äâèãàòåë çàâèñè îò óñëîâèòà, ï˜è

êîèòî ˜àáîòè è îò ã˜è¥èòå, êîèòî ïîëó…àâà. ‹êîè ï˜èëî¥åíè, êàòî

êóëòèâàòî˜è, ïîìïè, è ˜îòàöèîííè êîñà…êè, ìíîãî …åñòî ñå èçïîëçâàò â ï˜àμíà è

çàìú˜ñåíà ñ˜åäà, êîåòî ìî¥å äà äîâåäå äî ï˜åäâà˜èòåëíîòî èì èçíîñâàíå.

‚àêîâà èçíîñâàíå íå ñå ïîê˜èâà îò ãà˜àíöè

òà, êîãàòî ñå äúë¥è íà ì˜úñîòè,

ï˜àõ, àá˜àçèâ çà ïî…èñòâàíå íà ñâåùòà èëè ä˜óãè àá˜àçèâíè ìàòå˜èàëè,

ïîïàäíàëè â äâèãàòåë ïî˜àäè íåêà…åñòâåíî ïîääú˜¥àíå.

Òàçè ãàðàíöèÿ ïîêðèâà ñàìî

óïîòðåáåí â äâèãàòåëÿ äåôåêòåí ìàòåðèàë

è/èëè èçðàáîòêà, à íå çàìÿíàòà èëè âúçñòàíîâÿâàíåòî íà ìàøèíàòà, êúì

êîÿòî äâèãàòåëÿò ìîæå äà áúäå ìîíòèðàí. Ãàðàíöèÿòà íå ïîêðèâà è

ïîèñêàíè ðåìîíòè ïîðàäè:

1 Ïðîáëåìè, ïðè÷èíåíè îò ÷àñòè, êîèòî íå ñà îðèãèíàëíè ÷àñòè íà Briggs &

Stratton.

2 ‡ñò˜îéñòâà çà óï˜àâëåíèå íà ìàμèíàòà èëè ñúî˜ú¥åíè, êîèòî ï˜å…àò íà

ñòà˜òè˜àíåòî íà äâèãàòåë, âîäò äî íåçàäîâîëèòåëíàòà ìó ˜àáîòà èëè

ñêúñâàò ¥èâîòà ìó. (ÿîíñóëòè˜àéòå ñ å ñ ï˜îèçâîäèòåë íà óñò˜îéñòâàòà.)

3 ‚å…àùè êà˜áó˜àòî˜è, çàä˜úñòåíè ãî˜èâíè ò˜úáè, áëîêè˜àíè êëàïàíè èëè

ä˜óãè ïîâ˜åäè, ï˜è…èíåíè îò óïîò˜åáàòà íà çàìú˜ñåíî èëè îñòà˜ëî ãî˜èâî.

4 ˝àñòè, êîèòî ñà íàä˜àíè èëè ñ…óïåíè, çàùîòî äâèãàòåëò å ˜àáîòèë ñ

íåäîñòàòú…íî èëè çàìú˜ñåíî ìàñëî, èëè ñ ìàñëî ñ íåïîäõîäùî êà…åñòâî

(ï˜îâå˜âàéòå è äîëèâàéòå, êîãàòî å íåîáõîäèìî è ãî ñìåíâàéòå íà

ï˜åïî˜ú…âàíèòå èíòå˜âàëè îò â˜åìå.) æâà˜èéíîòî óñò˜îéñòâî OIL GARD

ìî¥å äà íå ñï˜å ˜àáîòåùè äâèãàòåë. æêî íèâîòî íà ìàñëîòî íå ñå ïîääú˜¥à

òî…íî, äâèãàòåëò ìî¥å äà ñå ïîâ˜åäè.

5 ˆåìîíò èëè ˜åãóëè˜àíå íà ìîíòè˜àíè …àñòè èëè àã˜åãàòè êàòî ñúåäèíèòåëè,

ï˜åäàâàòåëíè ìåõàíèçìè, äèñòàíöèîííè óï˜àâëåíè èä˜.,êîèòîíåñà

ï˜îèçâåäåíè îò Briggs & Stratton.

6 ﬁîâ˜åäà èëè èçíîñâàíå íà …àñòè, ï˜è…èíåíè îò íå…èñòîòè, ïîïàäíàëà â

äâèãàòåë, ïî˜àäè íåêà…åñòâåíî ïîääú˜¥àíå íà âúçäóμíè ôèëòú˜,

íåêà…åñòâåí ïîâòî˜åí ìîíòà¥ èëè îò èçïîëçâàíå íà íåî˜èãèíàëíè åëåìåíòè

çà ôèëòú˜à. ‹à ï˜åïî˜ú…âàíèòå èíòå˜âàëè îò â˜åìå ïî…èñòâàéòå è/èëè

ñìåíâàéòå ôèëòú˜à, êàêòî å ïîñî…åíî â ˆúêîâîäñòâîòî çà ˜àáîòà.

7 ˝àñòè, ïîâ˜åäåíè îò ï˜åâèμåíà ñêî˜îñò èëè ï˜åã˜âàíå, ï˜è…èíåíè îò ò˜åâè,

ïà˜…åòà èëè ì˜úñîòè ,êîòî çàïóμâà èëè çàä˜úñòâà îõëàäèòåëíèòå ˜åá˜à è

êàìå˜àòà íà ìàõîâèêà, èëè ïîâ˜åäà ïî˜àäè ˜àáîòà íà äâèãàòåë â çàòâî˜åíî

ï˜îñò˜àíñòâî áåç äîñòàòú…íî ï˜îâåò˜âàíå. ﬁî…èñòâàéòå äâèãàòåë îò

ïîïàäíàëè ïà˜…åòà íà ï˜åïî˜ú…âàíèòå èíòå˜âàëè îò â˜åìå, êàêòî å ïîñî…åíî

â ˆúêîâîäñòâîòî çà ˜àáîòà.

8 ˝àñòè íà äâèãàòåë èëè ìàμ

èíàòà, ñ…óïåíè îò ï˜åêîìå˜íà âèá˜àöè,

äúë¥àùà ñå íà õëàáàâ ìîíòà¥ íà äâèãàòåë, õëàáàâè ˜å¥åùè íî¥îâå,

õëàáàâè ïëàñòèíè è õëàáàâè èëè çëå áàëàíñè˜àíè ˜àáîòíè êîëåëà, íà

íåäîá˜î êóïëè˜àíå íà ìàμèíàòà êúì êîëåí…àòè âàë íà äâèãàòåë,íà

ñâ˜úõâèñîêè îáî˜îòè èëè ä˜óãà çëîóïîò˜åáà ï˜è ˜àáîòà.

9 ›ãúíàò èëè ñ…óïåí êîëåí…àò âàë âñëåäñòâèå íà óäà˜ â òâú˜ä ï˜åäìåò íà

˜å¥åùè íî¥ íà ˜îòàöèîííàòà ïîëåâà êîñà…êà èëè îò ï˜åêîìå˜íî íàòãàíå

íà ò˜àïåöîâèäíè ˜åìúê.

10 ˆóòèííà íàñò˜îéêà è ˜åãóëè˜îâêà íà äâèãàòåë.

11 ﬁîâ˜åäà íà äâèãàòåë èëè íà íåãîâ åëåìåíò, ò.å. ãî˜èâíà êàìå˜à, êëàïàíè,

êëàïàííè ëåãëà, êëàïàííè âîäà…è, èëè èçãî˜åëè íàìîòêè íà ñòà˜òå˜à ïî˜àäè

èçïîëçâàíåòî íà àëòå˜íàòèâíè ãî˜èâà êàòî íàôòà, ï˜è˜îäåí ãàç, áåíçèíè ñ

ï˜îìåíåíè êà…åñòâà è ò.í.

Ãàðàíöèîííîòî îáñëóæâàíå å äîñòúïíî åäèíñòâåíî ÷ðåç Óïúëíîìîùåíèòå

ñåðâèçíè ïðåäñòàâèòåëè íà Êîðïîðàöèÿ Briggs & Stratton. Íàìåðåòå

íàé-áëèçêèÿ Óïúëíîìîùåí ñåðâèçåí ïðåäñòàâèòåë â íàøàòà óêàçàòåëíà êàðòà

çà ïðåäñòàâèòåëèòå íà àäðåñ BRIGGSandSTRATTON.com, èëè êàòî ñå îáàäèòå

íà òåë. 1-800-233-3723, èëè êàêòî å ïîñî÷åíî â ‘Æúëòèòå ñòðàíèöèt’.

18 BRIGGSandSTRATTON.COM

Všeobecné informace

Potøebujete-li náhradní díly nebo technickou pomoc, zapište dolù model motoru, typové a

kódové èíslo a datum nákupu. Tato naleznete na svém motoru (viz kapitola Funkce a

ovládací prvky).

Datum nákupu:

Model motoru:

DD/MM/RRRR

Model: Kód:Typ:

Informace o jmenovitém výkonu motoru

Hrubý výkon jednotlivých modelù benzínových motorù je uvádìn v souladu s normou

J1940 pro postup pøi stanovování výkonu a k r outicího momentu u malých motorù (Small

Engine Power & Torque Rating Procedure) vydanou asociací SAE (Society of

Automotive Engineers) a výkon byl získán a pøepoèten v souladu s normou SAE J1995

(revize 2002-05). Hodnoty krouticího momentu byly získány pøi 3060 RPM (ot./min.) a

hodnoty výkonu v koních byly získány pøi 3600 RPM (ot./min.) Skuteèný hrubý výkon

motoru bude nižší, což je, mimo jiné, ovlivnìno provozními podmínkami prostøedí a

rozdíly mezi jednotlivými vyrobenými kusy motorù. Z dùvodu široké škály produktù, do

nichž se naše motory umísují, a rùzných ekologických faktorù vztahujících se k provozu

zaøízení, nemusí benzínový motor pøi použití v konkrétním druhu zaøízení dosahovat

nominálního hrubého výkonu (skuteèného výkonu „na místì instalace” nebo èistého

výkonu). Tento rozdíl je zpùsoben mnoha faktory, mezi nìž patøí použité pøíslušenství

(jako je napøíklad vzduchový f iltr, výfuk, plnìní, chlazení, karburátor, palivové èerpadlo

atd.), omezení využití, provozní podmínky prostøedí (teplota, vlhkost, nadmoøská výška)

a rozdíly mezi jednotlivými vyrobenými kusy motoru. V dùsledku výrobních a kapacitních

omezení mùže spoleènost Briggs & Stratton nahradit motor této série motorem o vyšším

nominálním výkonu.

Bezpeènost obsluhy

Výbuch

Toxické výparyPohyblivé èásti

Úraz elektrickým

proudem

Horký povrch

Zpìtný ráz

Požár

Uzávìr paliva

Ètìte návod

Sytiè

Olej

Palivo

Zapnuto/Vypnuto

Stop

Používejte

ochranu zraku

Pomalu

Rychle

BEZPEÈNOSTNÍ A KONTROLNÍ SYMBOLY

Nebezpeèná chemikálie Omrzlina

Symbol bezpeènostního upozornìní

oznaèuje bezpeènostní informace týkající se

rizik, která mohou zpùsobit úraz. Signální slovo (NEBEZPEÈÍ, UPOZORNÌNÍ nebo

VÝSTRAHA) se používá spolu s varovným symbolem pro vyznaèení pravdìpodobnosti a

potenciální vážnosti úrazu. Mimo to mùže být pro oznaèení druhu nebezpeèí použit symbol

nebezpeèí.

NEBEZPEÈÍ oznaèuje ohrožení, které, není-li eliminováno, zpùsobí smrt

nebo vážný úraz.

VAROVÁNÍ oznaèuje ohrožení, které, není-li eliminováno, mùže zpùsobit

smrt nebo vážný úraz.

POZOR oznaèuje ohrožení, které, není-li eliminováno, mùže zpùsobit lehký,

nebo støednì tìžký úraz.

POZOR, pokud se použije bez varovného symbolu, oznaèuje situaci, vnížby

mohlo dojít k poškození produktu.

Výfukové plyny tohoto výrobku obsahují chemikálie, o nichž je ve státì

Kalifornie známo, že zpùsobují rakovinu, poškození plodu èi jiné poruchy

reprodukce.

VAROVÁNÍ

Briggs & Stratton neschvaluje ani nepovoluje použití tìchto motorù na

tøíkolových terénních vozidlech (ATV), motocyklech, zábavních/rekreaèních

motokárách, letadlech nebo vozidlech urèených pro sportovní soutìže. Takové

použití tìchto motorù by mohlo vést ke škodám na majetku, vážnému zranìní

(vèetnì ochrnutí) nebo i k e smrtelnému úrazu.

VAROVÁNÍ

POZOR: Tento motor byl odeslán spoleèností Briggs & Stratton bez oleje. Než motor

nastartujete, ještì jednou zkontrolujte, zda jste doplnili olej podle pokynù uvedených v

této pøíruèce. Jestliže nastartujete motor bez oleje, znièí se tak, že už nepùjde opravit a

nebude kryt žádnou zárukou.

Benzin a jeho páry jsou vysoce hoølavé a výbušné.

Požár nebo výbuch mùže zpùsobit vážné popáleniny nebo i smrt.

VAROVÁNÍ

Když doplòujete palivo

• Vypnìte motor a pøed sejmutím uzávìru palivové nádrže jej nec hte nejménì 2

minuty chladnout.

• Nádrž plòte venku nebo v dobøe v ìtraném prostoru.

• Nepøeplòujte palivovou nádrž. Nádrž plòte zhruba 38mm (1,5 in) pod horní okraj

hrdla kvùli tepelné roztažnosti paliva.

• Benzín chraòte pøed jiskrami, otevøeným ohnìm, vìènými plamínky, horkem a

jinými zdroji vznícení.

• Kontrolujte palivové potrubí, nádrž a víèko a všechny spoje na tìsnost a

praskliny. V pøípadì potøeby proveïte výmìnu.

• Jestliže rozlijete palivo, poèkejte, až se odpaøí a t eprve potom spuste motor.

Pøi spouštìní motoru

• Zkontrolujte, zda jsou na svém místì svíèky, tlumiè výfuku, víèko palivové nádrže a

vzduchový filtr (je-li k dispozici), a zda jsou dobøe zajištìny.

• Neotáèejte motorem pøi odstranìné svíèce.

• Pøi pøeplavení motoru nastavte sytiè (je-li k dispozici) do polohy OPEN/RUN (chod)

a škrtící klapku do polohy FAST (rychle) a protáèejte motor, dokud nenaskoèí.

Pøi obsluze zaøízení

• Nenaklánìjte motor ani zaøízení do polohy, která by zpùsobila únik benzínu.

• Motor se nesmí zastavovat zahlcením karburátoru.

• Nikdy nestartujte ani nenechte bìžet motor s demontovanou sestavou vzduchového

èistièe nebo filtru (je-li k dispozici).

Pøi výmìnì oleje

• když vypouštíte olej z horní plnící olejové trubky, musí být palivová nádrž prázdná,

protože jinak mùže palivo unikat z nádrže a zpùsobit požár nebo explozi.

Pøi pøepravì zaøízení

• Zaøízení pøepravujte s PRÁZDNOU palivovou nádrží nebo zavøeným palivovým

kohoutem.

Pøi skladování benzínu nebo zaøízení s palivem v nádrži

• Uchovávejte oddìlenì od pecí, kamen, ohøívaèù vody èi jiných zaøízení, k terá mají

vìèný plamínek nebo od jiných zdrojù zapálení. Mohou zažehnout benzinové páry.

Spouštìní motoru je doprovázené jiskøením.

Jiskøení mùže zažehnout pøítomné hoølavé plyny.

Výsledkem mùže být požár nebo výbuch.

VAROVÁNÍ

• Nespouštìjte motor, uniká-li v prostoru zemní plyn nebo propan-butan (LPG).

• Nepoužívejte stlaèené startovací kapaliny, jejich páry jsou hoølavé.

Motory produkují oxid uhelnatý, což je bezbarvý jedovatý plyn bez

zápachu.

Vdechování oxidu uhelnatého mùže zpùsobit nevolnost, mdloby až smrt.

VAROVÁNÍ

• Spouštìjte a provozujte motor venku.

• Nespouštìjte ani neprovozujte motor v uzavøeném prostoru, i když jsou otevøená

okna i dveøe.

Rychlé zatažení (zpìtné ”kopnutí”) lanka spouštìèe pøitáhne ruku a paži k

motoru rychleji, než ho staèíte pustit.

Je tu nebezpeèí zlomeniny, odøení nebo natažení šlach.

VAROVÁNÍ

• Pøi startování motoru táhnìte za lanko spouštìèe pomalu, dokud neucítíte odpor a

pak rychle zatáhnìte, abyste zabránili zpìtnému kopnutí.

• Pøed spuštìním motoru zbavte motor veškerého vnìjšího vybavení/zátìže.

• Pøímo spøažené souèásti zaøízení, napø. nože, obìžná kola, øemenice, ozubená kola

atd., musí být bezpeènì upevnìny.

Otáèivé èásti se mohou dostat do styku nebo zachytit ruce, nohy, vlasy,

odìv èi výstroj.

Mùže dojít k tìžkým tržným ranám až amputacím konèetin.

VAROVÁNÍ

• Provozujte zaøízení pouze s upevnìnými ochrannými kryty.

• Nepøibližujte ruce a nohy k rotujícím èástem.

• Sepnìte si dlouhé vlasy a sejmìte šperky.

• Nenoste volnì v lající odìv, volnì visící stahovací tkalouny a šòùry, jež mohou být

zachyceny.

Provozem motorù se vytváøí teplo. Díly motoru, zejména tlumiè výfuku,

jsou za provozu extrémnì horké.

Ve styku s nimi mohou vzniknout vážné popáleniny.

Hoølavý materiál, jako je listí, tráva, roští atd., mùže vzplanout.

VAROVÁNÍ

• Pøed manipulací nechejte tlumiè výfuku, válec a žebra motoru vychladnout.

• Odstraòujte hoølavé neèistoty, hromadící se v prostoru tlumièe a válce.

• Pøed použitím zaøízení na zalesnìném, t ravnatém nebo køovím porostlém

nekultivovaném pozemku namontujte a udržujte ve funkèním stavu lapaè jisker.

Vyžaduje to stát Kalifornie (paragraf 4442 Kalifornského zákona o veøejných

zdrojích). Ostatní státy mají podobné zákony. Na federálních pozemcích platí

federální zákony.

Neúmyslné jiskøení mùže zpùsobit požár nebo úraz elektrickým proudem.

Neúmyslné spuštìní motoru mùže zpùsobit zachycení, amputaci konèetiny

nebo tržné rány.

Riziko požáru

VAROVÁNÍ

Pøed provádìním seøizování nebo oprav:

• Odpojte kabel od zapalovací svíèky a uložte jej dále od zapalovací svíèky.

• Odpojte kabel od záporného vývodu akumulátoru (jen pokud je motor vybaven

elektrickým spouštìèem).

• Používejte pouze s právné nástroje.

• Otáèky motoru se nesmí zvyšovat úpravami pružin regulátoru, táhel a ostatních dílù.

• Náhradní díly tlumièe výfuku musí být stejné jako originály a namontované na

pùvodních místech.

• Na setrvaèník netluète k ladivem nebo tvrdým pøedmìtem, protože hrozí rozpad

setrvaèníku pøi dalším provozu.

Pøi zkoušení svíèky:

• Použijte schválenou zkoušeèku zapalovacích svíèek

• Nezkoušejte jiskru z apalování pøi vyjmuté svíèce.

20 BRIGGSandSTRATTON.COM

Funkce a ovládací prvky

Abyste s e s eznámili s umístìním rùzných funkcí a ovládacích prvkù, porovnávejte

ilustrace

s motorem.

A. Identifikace motoru

Model Typ Kód

B. Zapalovací svíèka

C. Vzduchový filtr

D. Sytiè

E. Rukoje lanka spouštìèe

F. Palec svíèky

G. Ovladaè škrtící klapky (volitelný)

H. Spínaè (volitelný)

I. Palivová nádrž a víèko

J. Vypouštìcí zátka oleje

K. Plnicí hrdlo oleje

L. Tlumiè výfuku

Kryt tlumièe (volitelný)

Jiskrojem (volitelný)

M. Jednotka redukèního pøevodu (volitelný)

Fungování

Objem oleje (viz sekci Specifikace)

Doporuèené oleje

Pro optimální výkon doporuèujeme používat oleje Briggs & Stratton s e z áruèním

certifikátem. Jsou pøípustné i další vysoce kvalitní detergentní oleje s klasifikací pro

provoz SF, SG, SH, SJ nebo vyšší. Nepoužívejte speciální pøísady.

Správná viskozita oleje pro motor je závislá na venkovní teplotì. S pomocí tabulky zvolte

nejlepší viskozitu pro oèekávaný rozsah venkovních teplot.

SAE 30

10W-30

Syntetický olej 5W-30

5W-30

°F °C

* Používání oleje SAE 30 pøi teplotách nižších než 40°F(4°C) bude mít za následek

obtížné startování.

** Pøi teplotách vyšších než 80°F(27°C) mùže zpùsobit použití oleje10W-30 zvýšení

spotøeby oleje. Kontrolujte hladinu oleje èastìji.

Kontrola/dolití oleje - Obrázek

Pøed pøidáním nebo kontrolou oleje

• Motor dejte do vodorovné polohy.

• Vyèistìte prostor pro doplòování oleje od neèistot.

1. Sejmìte uzávìr plnicího otvoru oleje (A, Obrázek 2).

2. Pøi doplòování oleje nalévejte olej pomalu do nalévacího otvoru motoru (B). Naplòte

až do pøeteèení.

3. Vrate uzávìr na místo a utáhnìte ho.

Doporuèení týkající se benzínu

Palivo musí splòovat následující požadavky:

• Používejte èistý, èerstvý bezolovnatý benzín.

• Minimálnì 87 oktanù/87 AKI (91 RON). V pøípadì, že používáte stroj ve vyšších

nadmoøských výškách, viz níže.

• Pøijatelný je benzín obsahující do 10 % ethanolu (smìsi benzínu s alkoholem)

nebo do 15 % MTBE (methyl-tercio-butyl-ether).

UPOZORNÌNÍ: Nepoužívejte neschválený benzín, jako napøíklad E85. Nepøidávejte do

benzínu olej ani neupravujte motor pro provoz s alternativními palivy. Došlo by k

poškození souèástí motoru a ztrátì záruky na motor.

Do paliva pøidávejte stabilizátor paliva, abyste zabránili tvorbì gumy v palivové soustavì.

Viz Skladování. Všechna paliva nejsou stejná. Pokud se objeví problémy se spouštìním

nebo výkonností motoru, zmìòte dodavatele paliva nebo znaèku. Tento motor je úøednì

schválen jako benzínový motor. Systém øízení emisí tohoto motoru je EM (Engine

Modifications).

Vìtší nadmoøské výšky

Ve výškách nad 1 524 m (5 000 stop) je pøípustný minimálnì 85oktanový/85 AKI (89

RON) benzín. Aby byly dodrženy emisní limity, musí být motor pro vyšší nadmoøské

výšky seøízen. Provoz bez tohoto seøízení zpùsobí sníženou výkonnost, zvýšenou

spotøebu paliva a zvýšené emise. Informace o seøízení pro vyšší nadmoøské výšky

získáte u autorizovaného prodejce znaèky Briggs & Stratton.

Provoz motoru pøí nadmoøských výškách pod 762 m (2 500 stop) s pøestavbou pro vyšší

nadmoøské výšky se nedoporuèuje.

Doplnìní paliva - Obrázek

Benzin a jeho páry jsou vysoce hoølavé a výbušné.

Požár nebo výbuch mùže zpùsobit vážné popáleniny nebo i smrt.

VAROVÁNÍ

Když doplòujete palivo

• Vypnìte motor a pøe d sejmutím uzávìru palivové nádrže jej nechte nejménì 2

minuty chladnout.

• Nádrž plòte venku nebo v dobøe v ìtraném prostoru.

• Nepøeplòujte palivovou nádrž. Nádrž plòte zhruba 1.5 palce (38 mm) pod horní

okraj hrdla kvùli tepelné roztažnosti paliva.

• Benzín chraòte pøed jiskrami, otevøeným ohnìm, vìènými plamínky, horkem a

jinými zdroji vznícení.

• Zkontrolujte palivové potrubí, nádrž a uzávìr a všechny spoje na tìsnost a

praskliny. V pøípadì potøeby proveïte výmìnu.

• Jestliže rozlijete palivo, poèkejte, až se odpaøí a t eprve potom spuste motor.

1. Vyèistìte okolí uzávìru paliva od špíny a neèistot. Sejmìte uzávìr palivové nádrže

(A)(Obrázek3).

2. Naplòte palivovou nádrž (B) benzínem. Kvùli tepelné roztažnosti paliva, naplòte

nádrž jen po spodní okraj hrdla (C).

3. Nasaïte uzávìr palivové nádrže.

Jak nastartovat motor - Obrázek

Rychlé zatažení (zpìtné ”kopnutí”) lanka spouštìèe pøitáhne ruku a paži k

motoru rychleji, než ho staèíte pustit.

Je tu nebezpeèí zlomeniny, odøení nebo natažení šlach.

VAROVÁNÍ

• Pøi startování motoru táhnìte za lanko spouštìèe pomalu, dokud neucítíte odpor a

pak rychle zatáhnìte, abyste zabránili zpìtnému kopnutí.

Benzin a jeho páry jsou vysoce hoølavé a výbušné.

Požár nebo výbuch mùže zpùsobit vážné popáleniny nebo i smrt.

VAROVÁNÍ

Pøi spouštìní motoru

• Zkontrolujte, zda jsou na svém místì svíèky, tlumiè výfuku, víèko palivové nádrže a

vzduchový filtr, a zda jsou dobøe zajištìny.

• Neotáèejte motorem pøi odstranìné svíèce.

• Pøi pøeplavení motoru nastavte sytiè (je-li k dispozici) do polohy open /run (chod) a

škrtící klapku do polohy fast (rychle) a protáèejte motor, dokud nenaskoèí.

Motory produkují oxid uhelnatý, což je bezbarvý jedovatý plyn bez

zápachu.

Vdechování oxidu uhelnatého mùže zpùsobit nevolnost, mdloby až smrt.

VAROVÁNÍ

• Spouštìjte a provozujte motor venku.

• Nespouštìjte ani neprovozujte motor v uzavøeném prostoru, i když jsou otevøená

okna i dveøe.

POZOR: Tento motor byl odeslán spoleèností Briggs & Stratton bez oleje. Než motor

nastartujete, ještì jednou zkontrolujte, zda jste doplnili olej podle pokynù uvedených v

této pøíruèce. Jestliže nastartujete motor bez oleje, poškodí se tak, že už nepùjde opravit

a nebude kryt žádnou zárukou.

1. Zkontrolujte stav oleje. Viz èást Kontrola/doplòování oleje .

2. Zkontrolujte, zda jsou ovládací prvky pohonu (pokud je jimi zaøízení vybaveno)

vypnuty. V pøíruèce zaøízení vyhledejte umístìní a fungování tìchto ovládacích

prvkù.

3. Posuòte ovládání sytièe (A) do polohy choke

(Obrázek 4).

Stránka sa načítava...

Simplicity 095402-0114-B1 Používateľská príručka

Súvisiace články